Skip to main content
NCBI home page
Occupational and Environmental Medicine logoLink to Occupational and Environmental Medicine
. 2001 Oct;58(10):649–655. doi: 10.1136/oem.58.10.649

Experimental exposure to propylene glycol mist in aviation emergency training: acute ocular and respiratory effects

G Wieslander 1, D Norback 1, T Lindgren 1
PMCID: PMC1740047  PMID: 11555686

Abstract

OBJECTIVES—Propylene glycol (PG) (1-2 propanediol; CAS No 57-55-6) is a low toxicity compound widely used as a food additive, in pharmaceutical preparations, in cosmetics, and in the workplace—for example, water based paints, de-icing fluids, and cooling liquids. Exposure to PG mist may occur from smoke generators in discotheques, theatres, and aviation emergency training. Propylene glycol may cause contact allergy, but there is sparse information on health effects from occupational exposure to PG.
METHODS—Non-asthmatic volunteers (n=27) were exposed in an aircraft simulator to PG mist over 1 minute, during realistic training conditions. Geometric mean concentration of PG was 309 mg/m3 (range 176-851 mg/m3), with the highest concentrations in the afternoon. The medical investigation was performed both before and after the exposure (within 15 minutes). It included an estimate of tear film stability break up time, nasal patency by acoustic rhinometry, dynamic spirometry, and a doctor's administered questionnaire on symptoms.
RESULTS—After exposure to PG mist for 1 minute tear film stability decreased, ocular and throat symptoms increased, forced expiratory volume in 1 second/forced vital capacity (FEV1/FVC) was slightly reduced, and self rated severity of dyspnoea was slightly increased. No effect was found for nasal patency, vital capacity (VC), FVC, nasal symptoms, dermal symptoms, smell of solvent, or any systemic symptoms. Those exposed to the higher concentrations in the afternoon had a more pronounced increase of throat symptoms, and a more pronounced decrease of tear film stability. In four subjects who reported development of irritative cough during exposure to PG, FEV1 was decreased by 5%, but FEV1 was unchanged among those who did not develop a cough. Those who developed a cough also had an increased perception of mild dyspnoea.
CONCLUSION—Short exposure to PG mist from artificial smoke generators may cause acute ocular and upper airway irritation in non-asthmatic subjects. A few may also react with cough and slight airway obstruction.


Keywords: acoustic rhinometry; aviation medicine; propylene glycol; respiratory symptoms; tear film stability break up time

Full Text

The Full Text of this article is available as a PDF (146.3 KB).

Selected References

These references are in PubMed. This may not be the complete list of references from this article.

  1. Andersson K., Hallgren C., Levin J. O., Nilsson C. A. Chemosorption sampling and analysis of formaldehyde in air. Influence on recovery during the simultaneous sampling of formaldehyde, phenol, furfural and furfuryl alcohol. Scand J Work Environ Health. 1981 Dec;7(4):282–289. doi: 10.5271/sjweh.2546. [DOI] [PubMed] [Google Scholar]
  2. Beach J. R., Raven J., Ingram C., Bailey M., Johns D., Walters E. H., Abramson M. The effects on asthmatics of exposure to a conventional water-based and a volatile organic compound-free paint. Eur Respir J. 1997 Mar;10(3):563–566. [PubMed] [Google Scholar]
  3. Casazza J. P., Song B. J., Veech R. L. Short chain diol metabolism in human disease states. Trends Biochem Sci. 1990 Jan;15(1):26–30. doi: 10.1016/0968-0004(90)90127-w. [DOI] [PubMed] [Google Scholar]
  4. Chang J. C., Sparks L. E., Guo Z., Fortmann R. Evaluation of sink effects on VOCs from a latex paint. J Air Waste Manag Assoc. 1998 Oct;48(10):953–958. [PubMed] [Google Scholar]
  5. Demey H. E., Daelemans R. A., Verpooten G. A., De Broe M. E., Van Campenhout C. M., Lakiere F. V., Schepens P. J., Bossaert L. L. Propylene glycol-induced side effects during intravenous nitroglycerin therapy. Intensive Care Med. 1988;14(3):221–226. doi: 10.1007/BF00717993. [DOI] [PubMed] [Google Scholar]
  6. Fisher A. A. Systemic contact dermatitis caused by ingestion of certain foods in propylene glycol-sensitive patients. Am J Contact Dermat. 1996 Dec;7(4):259–259. [PubMed] [Google Scholar]
  7. Funk J. O., Maibach H. I. Propylene glycol dermatitis: re-evaluation of an old problem. Contact Dermatitis. 1994 Oct;31(4):236–241. doi: 10.1111/j.1600-0536.1994.tb01995.x. [DOI] [PubMed] [Google Scholar]
  8. Glover M. L., Reed M. D. Propylene glycol: the safe diluent that continues to cause harm. Pharmacotherapy. 1996 Jul-Aug;16(4):690–693. [PubMed] [Google Scholar]
  9. Goldsmith L. A. Propylene glycol. Int J Dermatol. 1978 Nov;17(9):703–705. doi: 10.1111/ijd.1978.17.9.703. [DOI] [PubMed] [Google Scholar]
  10. Gonzalo M. A., de Argila D., García J. M., Alvarado M. I. Allergic contact dermatitis to propylene glycol. Allergy. 1999 Jan;54(1):82–83. doi: 10.1034/j.1398-9995.1999.00047.x. [DOI] [PubMed] [Google Scholar]
  11. Greenbaum J., Leznoff A., Schulz J., Mazza J., Tobe A., Miller D. Comparative tolerability of two formulations of Rhinalar (flunisolide) nasal spray in patients with seasonal allergic rhinitis. Ann Allergy. 1988 Oct;61(4):305–310. [PubMed] [Google Scholar]
  12. Gérin M., Patrice S., Bégin D., Goldberg M. S., Vyskocil A., Adib G., Drolet D., Viau C. A study of ethylene glycol exposure and kidney function of aircraft de-icing workers. Int Arch Occup Environ Health. 1997;69(4):255–265. doi: 10.1007/s004200050145. [DOI] [PubMed] [Google Scholar]
  13. Laitinen J., Liesivuori J., Savolainen H. Exposure to glycols and their renal effects in motor servicing workers. Occup Med (Lond) 1995 Oct;45(5):259–262. doi: 10.1093/occmed/45.5.259. [DOI] [PubMed] [Google Scholar]
  14. Meltzer E. O., Orgel H. A., Bush R. K., Haltom J. R., Metzger W. J., Moss B. A., Mitchell D. Q., Ballas Z. K., Seltzer J. M., Shapiro G. G. Evaluation of symptom relief, nasal airflow, nasal cytology, and acceptability of two formulations of flunisolide nasal spray in patients with perennial allergic rhinitis. Ann Allergy. 1990 Jun;64(6):536–540. [PubMed] [Google Scholar]
  15. Millqvist E., Bengtsson U., Löwhagen O. Provocations with perfume in the eyes induce airway symptoms in patients with sensory hyperreactivity. Allergy. 1999 May;54(5):495–499. doi: 10.1034/j.1398-9995.1999.00031.x. [DOI] [PubMed] [Google Scholar]
  16. Millqvist E. Cough provocation with capsaicin is an objective way to test sensory hyperreactivity in patients with asthma-like symptoms. Allergy. 2000 Jun;55(6):546–550. [PubMed] [Google Scholar]
  17. Nihlén A., Wâlinder R., Löf A., Johanson G. Experimental exposure to methyl tertiary-butyl ether. II. Acute effects in humans. Toxicol Appl Pharmacol. 1998 Feb;148(2):281–287. doi: 10.1006/taap.1997.8342. [DOI] [PubMed] [Google Scholar]
  18. Norbäck D., Björnsson E., Janson C., Widström J., Boman G. Asthmatic symptoms and volatile organic compounds, formaldehyde, and carbon dioxide in dwellings. Occup Environ Med. 1995 Jun;52(6):388–395. doi: 10.1136/oem.52.6.388. [DOI] [PMC free article] [PubMed] [Google Scholar]
  19. Peleg O., Bar-Oz B., Arad I. Coma in a premature infant associated with the transdermal absorption of propylene glycol. Acta Paediatr. 1998 Nov;87(11):1195–1196. doi: 10.1080/080352598750031211. [DOI] [PubMed] [Google Scholar]
  20. Skaare A., Kjaerheim V., Barkvoll P., Rølla G. Skin reactions and irritation potential of four commercial toothpastes. Acta Odontol Scand. 1997 Apr;55(2):133–136. doi: 10.3109/00016359709115405. [DOI] [PubMed] [Google Scholar]
  21. Spreux A., Boyer A., Baldin B., Chichmanian R. M. Toux ou crise d'asthme déclenchés par le propylèneglycol. Therapie. 1996 Sep-Oct;51(5):561–562. [PubMed] [Google Scholar]
  22. Suber R. L., Deskin R., Nikiforov I., Fouillet X., Coggins C. R. Subchronic nose-only inhalation study of propylene glycol in Sprague-Dawley rats. Food Chem Toxicol. 1989 Sep;27(9):573–583. doi: 10.1016/0278-6915(89)90016-1. [DOI] [PubMed] [Google Scholar]
  23. Wahlberg J. E. Erythema-inducing effects of solvents following epicutaneous administration to man--studied by laser Doppler flowmetry. Scand J Work Environ Health. 1984 Jun;10(3):159–162. doi: 10.5271/sjweh.2351. [DOI] [PubMed] [Google Scholar]
  24. Wieslander G., Lindgren T., Norbäck D., Venge P. Changes in the ocular and nasal signs and symptoms of aircrews in relation to the ban on smoking on intercontinental flights. Scand J Work Environ Health. 2000 Dec;26(6):514–522. doi: 10.5271/sjweh.576. [DOI] [PubMed] [Google Scholar]
  25. Wieslander G., Norbäck D., Nordström K., Wålinder R., Venge P. Nasal and ocular symptoms, tear film stability and biomarkers in nasal lavage, in relation to building-dampness and building design in hospitals. Int Arch Occup Environ Health. 1999 Oct;72(7):451–461. doi: 10.1007/s004200050398. [DOI] [PubMed] [Google Scholar]
  26. Wyon N. M., Wyon D. P. Measurement of acute response to draught in the eye. Acta Ophthalmol (Copenh) 1987 Aug;65(4):385–392. doi: 10.1111/j.1755-3768.1987.tb07011.x. [DOI] [PubMed] [Google Scholar]
  27. Wålinder R., Norbäck D., Wieslander G., Smedje G., Erwall C., Venge P. Nasal patency and lavage biomarkers in relation to settled dust and cleaning routines in schools. Scand J Work Environ Health. 1999 Apr;25(2):137–143. doi: 10.5271/sjweh.416. [DOI] [PubMed] [Google Scholar]
  28. Xu D., Dhillon A. S., Abelmann A., Croft K., Peters T. J., Palmer T. N. Alcohol-related diols cause acute insulin resistance in vivo. Metabolism. 1998 Oct;47(10):1180–1186. doi: 10.1016/s0026-0495(98)90320-1. [DOI] [PubMed] [Google Scholar]
  29. Yorgin P. D., Theodorou A. A., Al-Uzri A., Davenport K., Boyer-Hassen L. V., Johnson M. I. Propylene glycol-induced proximal renal tubular cell injury. Am J Kidney Dis. 1997 Jul;30(1):134–139. doi: 10.1016/s0272-6386(97)90577-1. [DOI] [PubMed] [Google Scholar]

Articles from Occupational and Environmental Medicine are provided here courtesy of BMJ Publishing Group

RESOURCES