Skip to main content
PMC home page
Occupational and Environmental Medicine logoLink to Occupational and Environmental Medicine
. 2004 Aug;61(8):697–702. doi: 10.1136/oem.2003.011171

Evaluation of the protective effectiveness of gloves from occupational exposure to 2-methoxyethanol using the biomarkers of 2-methoxyacetic acid levels in the urine and plasma

H Chang 1, C Lin 1, T Shih 1, H Chan 1, J Chou 1, Y Huang 1
PMCID: PMC1740814  PMID: 15258277

Abstract

Aims: To evaluate the protective effectiveness of gloves from occupational exposure to 2-methoxyethanol (2-ME); and to examine the association of 2-methoxyacetic acid (MAA) in urine and plasma collected simultaneously from low 2-ME exposure and high 2-ME exposure workers in a semiconductor copper laminate circuit board manufacturing plant.

Methods: Eight hour time weighted breathing zone monitoring was performed to verify the 2-ME exposure classification between workers in regular and special operations. Urine and plasma samples were simultaneously collected from 74 exposed and 80 non-exposed workers. MAA concentrations in the urine (UMAA) and plasma (PMAA) were measured using previously published methods. Three types of gloves worn by workers (cotton, rubber, and no gloves) were recorded by direct observations in the workplace and validated by person-to-person interview. Protective effectiveness indices (PEI) were used to evaluate the glove effectiveness.

Results: There was no detectable 2-ME/MAA in the air, or in urine and plasma samples in non-exposed workers. The average UMAA and PMAA in special operations were 72.63 mg/g Cr. and 29.72 mg/l, significantly higher than values in regular operations (5.44 mg/g Cr. and 2.58 mg/l, respectively). PMAA showed satisfactory correlation to UMAA in all participants from both regular and special operations. The rubber gloves provided significant reduction in 2-ME uptake, whereas cotton gloves provided little protection with fluctuating effectiveness, based on PEI estimates.

Conclusions: PMAA, similar to UMAA, could serve as a specific biomarker for 2-ME exposure. Wearing impermeable rubber gloves during high risk tasks can reduce major 2-ME exposure. Other improvements, including engineering control, should be provided to diminish worker exposure to 2-ME in occupational environments.

Full Text

The Full Text of this article is available as a PDF (217.2 KB).

Selected References

These references are in PubMed. This may not be the complete list of references from this article.

  1. Cohen R. Reversible subacute ethylene glycol monomethyl ether toxicity associated with microfilm production: a case report. Am J Ind Med. 1984;6(6):441–446. doi: 10.1002/ajim.4700060607. [DOI] [PubMed] [Google Scholar]
  2. Dugard P. H., Walker M., Mawdsley S. J., Scott R. C. Absorption of some glycol ethers through human skin in vitro. Environ Health Perspect. 1984 Aug;57:193–197. doi: 10.1289/ehp.8457193. [DOI] [PMC free article] [PubMed] [Google Scholar]
  3. Groeseneken D., Veulemans H., Masschelein R., Van Vlem E. Experimental human exposure to ethylene glycol monomethyl ether. Int Arch Occup Environ Health. 1989;61(4):243–247. doi: 10.1007/BF00381421. [DOI] [PubMed] [Google Scholar]
  4. Groeseneken D., Veulemans H., Masschelein R., Van Vlem E. Experimental human exposure to ethylene glycol monomethyl ether. Int Arch Occup Environ Health. 1989;61(4):243–247. doi: 10.1007/BF00381421. [DOI] [PubMed] [Google Scholar]
  5. Johanson G., Boman A. Percutaneous absorption of 2-butoxyethanol vapour in human subjects. Br J Ind Med. 1991 Nov;48(11):788–792. doi: 10.1136/oem.48.11.788. [DOI] [PMC free article] [PubMed] [Google Scholar]
  6. Kezić S., Mahieu K., Monster A. C., de Wolff F. A. Dermal absorption of vaporous and liquid 2-methoxyethanol and 2-ethoxyethanol in volunteers. Occup Environ Med. 1997 Jan;54(1):38–43. doi: 10.1136/oem.54.1.38. [DOI] [PMC free article] [PubMed] [Google Scholar]
  7. Larese F., Fiorito A., De Zotti R. The possible haematological effects of glycol monomethyl ether in a frame factory. Br J Ind Med. 1992 Feb;49(2):131–133. doi: 10.1136/oem.49.2.131. [DOI] [PMC free article] [PubMed] [Google Scholar]
  8. Larese F., Fiorito A., De Zotti R. The possible haematological effects of glycol monomethyl ether in a frame factory. Br J Ind Med. 1992 Feb;49(2):131–133. doi: 10.1136/oem.49.2.131. [DOI] [PMC free article] [PubMed] [Google Scholar]
  9. Miller R. R., Carreon R. E., Young J. T., McKenna M. J. Toxicity of methoxyacetic acid in rats. Fundam Appl Toxicol. 1982 Jul-Aug;2(4):158–160. doi: 10.1016/s0272-0590(82)80039-0. [DOI] [PubMed] [Google Scholar]
  10. Miller R. R., Hermann E. A., Langvardt P. W., McKenna M. J., Schwetz B. A. Comparative metabolism and disposition of ethylene glycol monomethyl ether and propylene glycol monomethyl ether in male rats. Toxicol Appl Pharmacol. 1983 Feb;67(2):229–237. doi: 10.1016/0041-008x(83)90229-6. [DOI] [PubMed] [Google Scholar]
  11. Moss E. J., Thomas L. V., Cook M. W., Walters D. G., Foster P. M., Creasy D. M., Gray T. J. The role of metabolism in 2-methoxyethanol-induced testicular toxicity. Toxicol Appl Pharmacol. 1985 Jul;79(3):480–489. doi: 10.1016/0041-008x(85)90145-0. [DOI] [PubMed] [Google Scholar]
  12. Nagano K., Nakayama E., Oobayashi H., Nishizawa T., Okuda H., Yamazaki K. Experimental studies on toxicity of ethylene glycol alkyl ethers in Japan. Environ Health Perspect. 1984 Aug;57:75–84. doi: 10.1289/ehp.845775. [DOI] [PMC free article] [PubMed] [Google Scholar]
  13. Ohi G., Wegman D. H. Transcutaneous ethylene glycol monomethyl ether poisoning in the work setting. J Occup Med. 1978 Oct;20(10):675–676. [PubMed] [Google Scholar]
  14. Shih T-S, Hsieh A-T, Chen Y-H, Liao G-D, Chen C-Y, Chou J-S, Liou S-H. Follow up study of haematological effects in workers exposed to 2-methoxyethanol. Occup Environ Med. 2003 Feb;60(2):130–135. doi: 10.1136/oem.60.2.130. [DOI] [PMC free article] [PubMed] [Google Scholar]
  15. Shih T. S., Chen C. Y., Cheng R. I., Wu L. J. Field evaluation of a passive sampler for the exposure assessment of 2-methoxyethanol. Int Arch Occup Environ Health. 2000 Mar;73(2):98–104. doi: 10.1007/s004200050014. [DOI] [PubMed] [Google Scholar]
  16. Shih T. S., Chou J. S., Chen C. Y., Smith T. J. Improved method to measure urinary alkoxyacetic acids. Occup Environ Med. 1999 Jul;56(7):460–467. doi: 10.1136/oem.56.7.460. [DOI] [PMC free article] [PubMed] [Google Scholar]
  17. Shih T. S., Hsieh A. T., Liao G. D., Chen Y. H., Liou S. H. Haematological and spermatotoxic effects of ethylene glycol monomethyl ether in copper clad laminate factories. Occup Environ Med. 2000 May;57(5):348–352. doi: 10.1136/oem.57.5.348. [DOI] [PMC free article] [PubMed] [Google Scholar]
  18. Shih T. S., Liou S. H., Chen C. Y., Chou J. S. Correlation between urinary 2-methoxy acetic acid and exposure of 2-methoxy ethanol. Occup Environ Med. 1999 Oct;56(10):674–678. doi: 10.1136/oem.56.10.674. [DOI] [PMC free article] [PubMed] [Google Scholar]
  19. Shih T. S., Liou S. H., Chen C. Y., Smith T. J. Urinary 2-methoxy acetic acid accumulation in response to 2-methoxy ethanol exposure. Arch Environ Health. 2001 Jan-Feb;56(1):20–25. doi: 10.1080/00039890109604050. [DOI] [PubMed] [Google Scholar]
  20. Shih T. S., Wang P. Y., Chen C. Y., Smith T. J., Hu Y. P. Measurement of percutaneous uptake of 2-methoxy ethanol vapor in humans. J Occup Environ Med. 2000 May;42(5):475–482. doi: 10.1097/00043764-200005000-00003. [DOI] [PubMed] [Google Scholar]
  21. Sleet R. B., Greene J. A., Welsch F. The relationship of embryotoxicity to disposition of 2-methoxyethanol in mice. Toxicol Appl Pharmacol. 1988 Apr;93(2):195–207. doi: 10.1016/0041-008x(88)90120-2. [DOI] [PubMed] [Google Scholar]
  22. Welch L. S., Cullen M. R. Effect of exposure to ethylene glycol ethers on shipyard painters: III. Hematologic effects. Am J Ind Med. 1988;14(5):527–536. doi: 10.1002/ajim.4700140504. [DOI] [PubMed] [Google Scholar]
  23. Welch L. S., Schrader S. M., Turner T. W., Cullen M. R. Effects of exposure to ethylene glycol ethers on shipyard painters: II. Male reproduction. Am J Ind Med. 1988;14(5):509–526. doi: 10.1002/ajim.4700140503. [DOI] [PubMed] [Google Scholar]
  24. Wickramaratne G. A. The teratogenic potential and dose-response of dermally administered ethylene glycol monomethyl ether (EGME) estimated in rats with the Chernoff-Kavlock assay. J Appl Toxicol. 1986 Jun;6(3):165–166. doi: 10.1002/jat.2550060305. [DOI] [PubMed] [Google Scholar]
  25. Yonemoto J., Brown N. A., Webb M. Effects of dimethoxyethyl phthalate, monomethoxyethyl phthalate, 2-methoxyethanol and methoxyacetic acid on post implantation rat embryos in culture. Toxicol Lett. 1984 Apr;21(1):97–102. doi: 10.1016/0378-4274(84)90229-7. [DOI] [PubMed] [Google Scholar]
  26. Zellers E. T., Ke H. Q., Smigiel D., Sulewski R., Patrash S. J., Han M. W., Zhang G. Z. Glove permeation by semiconductor processing mixtures containing glycol-ether derivatives. Am Ind Hyg Assoc J. 1992 Feb;53(2):105–116. doi: 10.1080/15298669291359366. [DOI] [PubMed] [Google Scholar]

Articles from Occupational and Environmental Medicine are provided here courtesy of BMJ Publishing Group

RESOURCES