Skip to main content
PMC home page
AMB Express logoLink to AMB Express
. 2011 Mar 28;1:4. doi: 10.1186/2191-0855-1-4

A mutated xylose reductase increases bioethanol production more than a glucose/xylose facilitator in simultaneous fermentation and co-fermentation of wheat straw

Kim Olofsson 1, David Runquist 2,3, Bärbel Hahn-Hägerdal 2, Gunnar Lidén 1,✉
PMCID: PMC3159908  PMID: 21906329

Abstract

Genetically engineered Saccharomyces cerevisiae strains are able to ferment xylose present in lignocellulosic biomass. However, better xylose fermenting strains are required to reach complete xylose uptake in simultaneous saccharification and co-fermentation (SSCF) of lignocellulosic hydrolyzates. In the current study, haploid Saccharomyces cerevisiae strains expressing a heterologous xylose pathway including either the native xylose reductase (XR) from P. stipitis, a mutated variant of XR (mXR) with altered co-factor preference, a glucose/xylose facilitator (Gxf1) from Candida intermedia or both mXR and Gxf1 were assessed in SSCF of acid-pretreated non-detoxified wheat straw. The xylose conversion in SSCF was doubled with the S. cerevisiae strain expressing mXR compared to the isogenic strain expressing the native XR, converting 76% and 38%, respectively. The xylitol yield was less than half using mXR in comparison with the native variant. As a result of this, the ethanol yield increased from 0.33 to 0.39 g g-1 when the native XR was replaced by mXR. In contrast, the expression of Gxf1 only slightly increased the xylose uptake, and did not increase the ethanol production. The results suggest that ethanolic xylose fermentation under SSCF conditions is controlled primarily by the XR activity and to a much lesser extent by xylose transport.

Introduction

The yeast Saccharomyces cerevisiae has been extensively engineered for ethanolic fermentation of the pentose sugar xylose either by introducing genes encoding xylose reductase (XR) and xylitol dehydrogenase (XDH), or by introducing the gene encoding xylose isomerase (XI) (Hahn-Hägerdal et al. 2007; Van Vleet and Jeffries 2009; Matsushika et al. 2009). The aim is to achieve economically feasible ethanolic fermentation of hardwood and/or agricultural lignocellulose feedstock, since these raw materials have a high content of pentose sugars, primarily xylose (up to 20% of the dry matter) (USDE-database). Still xylose fermentation with recombinant S. cerevisiae is significantly less efficient than hexose fermentation. Among others this has been ascribed to the difference in cofactor preference of XR and XDH, which results in xylose to xylitol conversion rather than ethanolic fermentation (Bruinenberg et al. 1983). Site directed mutagenesis has been applied on the XR to change the co-factor affinity, e.g. (Watanabe et al. (2007)). A different approach was used by (Runquist et al. 2010a) who arrived at a mutated version of the XR with changed kinetic properties using a random method in combination with a selection system. The mutant XR (N272D) from Pichia stipitis (mXR) has an increased ratio of NADH/NADPH utilization and an order of magnitude higher Vmax compared to the native enzyme. The introduction of mXR in S. cerevisiae otherwise engineered for xylose fermentation translated directly into increased ethanol yield and ethanol productivity and reduced xylitol formation in synthetic medium.

Slow xylose fermentation has also been ascribed to be the less efficient xylose transport. In S. cerevisiae xylose and glucose compete for the same transport systems (Kilian and Uden 1988; Meinander and Hahn-Hägerdal 1997) and the affinity for xylose is orders of magnitude lower than for glucose (Kötter and Ciriacy 1993; Saloheimo et al. 2007; Gárdonyi et al. 2003). Several homologous and heterologous xylose transporters have been expressed in S. cerevisiae (Hamacher et al. 2002; Saloheimo et al. 2007; Runquist et al. 2009; Katahira et al. 2008; Hector et al. 2008). Among the heterologous transporters the glucose/xylose facilitator Gxf1 from Candida intermedia (Leandro et al. 2006) proved to have the highest transport capacity, which was reflected in the highest aerobic xylose growth rate (Runquist et al. 2010b). Gxf1 has also been expressed in the industrial xylose fermenting S. cerevisiae strain TMB3400 (Fonseca et al. submitted). Its presence increased xylose consumption in simultaneous saccharification and co-fermentation (SSCF) of acid-pretreated wheat straw, however, without increasing the ethanol yield.

Simultaneous saccharification and fermentation (SSF) (Takagi et al. 1977) has been established as a promising option for ethanol production from lignocellulosic materials (Olofsson et al. 2008a) since the overall ethanol yield has been reported to be higher than if the enzymatic hydrolysis and fermentation are carried out separately (SHF) (Wingren et al. 2003). Furthermore it also been established that xylose consumption increases in SSF (Öhgren et al. 2006; Olofsson et al. 2008b), which has therefore been re-named SSCF also to include co-fermentation of hexose and pentose sugar.

The current study was undertaken to investigate to what extent the presence of mXR instead of XR would allow ethanolic fermentation of the additional xylose taken up by strains carrying the Gxf1 facilitator (Fonseca et al. submitted). Therefore, isogenic haploid S. cerevisiae CEN.PK strains expressing a heterologous XR/XDH/XK pathway were constructed. In addition to the control strain carrying the native XR, strains carrying mXR, Gxf1 and both mXR and Gxf1 were generated. The strains were assessed in SSCF of acid-pretreated wheat straw. The presence of mXR significantly increased xylose uptake and ethanolic xylose fermentation and reduced xylitol formation. In contrast, Gxf1 either alone or together with mXR, at most increased xylose uptake with about 10% leaving the ethanol formation unchanged.

Materials and methods

Raw material and pretreatment

Wheat straw, locally harvested and dried in the field (Johan Håkansson Lantbruksprodukter, Lunnarp, Sweden), was milled and sieved into 1- to 10-mm pieces and soaked overnight in 0.2% (v/v) H2SO4 at room temperature in closed barrels at a solids loading of 10% (wt/wt). The impregnated straw was pressed to 300 bars and reached a dry matter content of 50%. It was subsequently steam-pretreated batchwise at 190°C for 10 min in a 10-L reactor described by (Palmqvist et al. (1996)). The pretreated material was stored at 4°C. The composition of the pretreatment slurry is presented in Table 1. The water-insoluble solids (WIS) and liquid fractions were analyzed using National Renewable Energy Laboratories (NREL) standard procedures (Sluiter et al. 2008a, b). The WIS content of the pretreated slurry was determined to be 13% (wt/wt) by washing the fibers with deionized water over filter paper.

Table 1.

Composition of the pretreated wheat straw material (WIS-content: 13.1%).

Content in solid fraction (% WIS) Content in liquid fraction (g L-1)
Glucan 53.3 Glucosea 9.3
Xylan 3.3 Xylosea 35.7
Lignin 34.5 Furfural 2.2
HMF < 0.1
Acetic acid 4.3
Open in a new tab

aBoth monomeric and oligomeric forms are included.

Strain construction

Standard molecular biology techniques were used for all cloning procedures (Sambrook et al. 1989). Fermentas GeneJet plasmid miniprep kit (Fermentas, Vilnius, Lithuania) was used for plasmid extraction and Qiagen Gel Extraction Kit (Qiagen GMBH, Hilden, Germany) was used to extract DNA from agarose gels. Restriction enzymes were obtained from Fermentas. The lithium acetate method was used for transformation of S. cerevisiae (Gietz et al. 1995). Homologs of the previously described xylose-utilizing strain TMB3422 and TMB3424 (Table 2) were constructed expressing the Gxf1 glucose/xylose transporter. Plasmid YIpDR7 and YIpOB8 were linearized using EcoRV and transformed into strain TMB 3043-Gxf1, yielding strains TMB3425 and TMB3426, respectively (Table 2).

Table 2.

S. cerevisiae strains and plasmids used in this study.

Strains and Plasmids Relevant Genotype Reference
Plasmids
YIpOB8 URA3 TDH3p-XYL1-ADH1t, PGK1p-XYL2-PGK1t (Bengtsson et al. 2009)
YIplac128 LEU2 (Gietz and Sugino 1988)
YIpDR1 YIplac128 TDH3p-GXF1-CYC1t (Runquist et al. 2009)
YIpDR7 pOB8 XR N272D (Runquist et al. 2010a)
S. cerevisiae strains
TMB 3043 CEN.PK 2-1C Δgre3, his3::PGK1p-XKS1-PGK1t, TAL1::PGK1p-TAL1-PGK1t, TKL1::PGK1p-TKL1-PGK1t, RKI1::PGK1p-RKI1-PGK1t, RPE1::PGK1p-RPE1-PGK1t, leu2, ura3 (Karhumaa et al. 2005)
TMB 3043-Gxf1 TMB 3043, leu2::YIpDR1, ura3 (Runquist et al. 2009)
TMB 3422 TMB 3043, leu2::YIplac128, ura3::YIpDR7 (Runquist et al. 2010a)
TMB 3424 TMB 3043, leu2::YIplac128, ura3:: YIpOB8 (Runquist et al. 2010a)
TMB 3425 TMB 3043, leu2::YIpDR1, ura3::YIpDR7 This work
TMB 3426 TMB 3043, leu2::YIpDR1, ura3::YIpOB8 This work
Open in a new tab

Cell propagation for SSCF

The recombinant xylose-fermenting strains S. cerevisiae TMB3422, TMB3424, TMB3425 and TMB3426 (Table 2) to be used in the SSCF were propagated in sequential cultures starting with a preculture in shake flask, followed by aerobic batch cultivation on glucose and finally aerobic fed-batch cultivation in wheat straw pretreatment liquid to improve inhibitor tolerance (Alkasrawi et al. 2006).

The yeast was inoculated in 300-ml flasks containing 100 ml media supplemented with 16.5 g L-1 glucose, 7.5 g L-1 (NH4)2SO4, 3.5 g L-1 KH2PO4, 0.74 g L-1 MgSO2·7H2O, trace metals and vitamins. The cells were grown for 24 h at 30°C and pH 5 in a rotary shaker at 180 rpm. Subsequently, aerobic batch cultivation was performed in a 2.5-L bioreactor (Biostat; A. B. Braun Biotech International, Melsungen, Germany) at 30°C. The working volume was 0.7 L, and the medium contained 20.0 g L-1 glucose, 20.0 g L-1 (NH4)2SO4, 10.0 g L-1 KH2PO4, 2.0 g L-1 MgSO4, 27.0 mL L-1 trace metal solution and 2.7 mL L-1 vitamin solution (Taherzadeh et al. 1996). The cultivation was initiated by adding 20.0 mL of the preculture to the bioreactor. The pH was maintained at 5.0 throughout the cultivation by automatic addition of 3 M NaOH. Aeration was maintained at 1.2 L min-1, and the stirrer speed was kept at 800 rpm. When the ethanol produced in the batch phase was depleted, the feeding of wheat straw pretreatment liquid was initiated. A total of 1.0 L of wheat straw pretreatment liquid was added starting with an initial feed rate of 0.04 L h-1, which was increased linearly to 0.10 L h-1 during 16 h of cultivation. The aeration during the fed-batch phase was maintained at 1.5 L min-1, and the stirrer speed was kept at 800 rpm.

Cells were harvested by centrifugation in 700-mL flasks using a HERMLE Z 513K centrifuge (HERMLE Labortechnik, Wehingen, Germany) and resuspended in 9 g L-1 NaCl solution to obtain a cell suspension for SSCF with 80 g dry wt L-1. The time between cell harvest and initiation of the SSCF was no longer than 3 h.

SSCF

All SSCF experiments were carried out batch-wise in duplicates under anaerobic conditions using 2.5-L bioreactors (Biostat; A. B. Braun Biotech International, Melsungen, Germany; Biostat A plus; Sartorius, Melsungen, Germany) sterilized by autoclavation. The experiments were carried out with a WIS content of 7% with a total working weight of 1.4 kg. To obtain the initially desired WIS content in the bioreactor, the pretreated, undetoxified slurry was diluted with sterile deionized water. Before adding the pretreated slurry to the reactor, pH was adjusted to 4.8 with the addition of 10 M NaOH. All SSCF experiments were carried out at 32°C for 96 h. pH was maintained at 5.0 throughout the SSCF by automatic addition of 3 M NaOH, and the stirring rate was kept at 500 rpm. The SSCF medium was supplemented with 0.5 g L-1 NH4H2PO4, 0.025 g L-1 MgSO4·7H2O and 1.0 g L-1 yeast extract. An initial yeast concentration of 4 g dry wt L-1 was used. The enzyme preparation was Cellic CTec (Novozymes A/S, Bagsvaerd, Denmark) with a FPU (filter paper units) activity of 95 FPU g-1 and a β-glucosidase activity of 590 IU g-1. The total amount of enzyme added to each SSCF experiment corresponded to 10 FPU (g WIS)-1 and 62.1 IU (g WIS)-1 β-glucosidase activity. Samples for high performance liquid chromatography (HPLC) analysis were taken repeatedly throughout the SSCF. All SSCF experiments were carried out in duplicates.

Analysis and calculation

The dry weight (DW) of the 9 g L-1 NaCl cell suspension (described above) was determined in duplicates from 10 mL samples centrifuged (1000 × g) for 5 min at 3000 rpm (Z200 A, HERMLE Labortechnik, Wehingen, Germany). Supernatants were discarded, and pellets were washed with 9 g L-1 NaCl solution and centrifuged a second time. Pellets were dried at 105°C overnight and weighed. FPU activity (Adney and Baker 1996) and β-glucosidase activity (1 IU corresponding to conversion of 1 μM substrate min-1) (Berghem and Pettersson 1973) were determined as previously described and modified (Olofsson et al. 2010). Substrates and products from the SSCF experiments were quantified by HPLC (Olofsson et al. 2010).

The ethanol yield, YE/S, was calculated on the basis of the total amount of fermentable sugars added to the SSCF, i.e., the sum of glucose and xylose present in the pretreatment slurry, including monomers, oligomers and polymers (glucan and xylan fibers). The theoretical mass of glucose released during hydrolysis is 1.11 times the mass of glucan (due to the addition of water). For xylose the corresponding number is 1.13 times the mass of xylan.

Results

The current study aimed to evaluate the relative contribution of a mutated xylose reductase (mXR) (Runquist et al. 2010a) and a glucose/xylose facilitator (Gxf1) (Runquist et al. 2009) (Fonseca et al. submitted) to the fermentation of xylose in a simultaneous saccharification and co-fermentation (SSCF) set-up (Olofsson et al. 2008a) of pretreated wheat straw. Independently mXR (Runquist et al. 2010a) and Gxf1 (Runquist et al. 2009) have been shown to increase the ethanolic fermentation of xylose in synthetic medium. To allow the comparison of these two genetic traits in an isogenic strain background - in SSCF of pretreated non-detoxified wheat straw - four differently engineered xylose-utilizing CEN.PK strains were constructed and compared; the control strain TMB3424 (Runquist et al. 2010a) harboring the native XR, strain TMB3422 harboring mXR and generated by introducing YIpDR7 (Runquist et al. 2010a) in strain TMB3043 (Karhumaa et al. 2005), strain TMB3426 harboring Gxf1 and generated by introducing YIpDR1 (Runquist et al. 2009) in TMB 3043, and strain TMB3425 harboring both mXR and Gxf1 and generated by introducing both YIpDR7 and YIpDR1 in strain TMB3043 (Table 2).

The control strain displayed a relatively slow fermentation of xylose (Figure 1A) and had at the end of the SSCF only consumed 38% of the available xylose (Table 3). Furthermore about one third, 32%, of the consumed xylose was secreted as xylitol so that only about 25% of the available xylose was fermented and contributed to the final ethanol concentration, 22.2 g L-1.

Figure 1.

Figure 1

Open in a new tab

Measured concentrations during duplicate batch SSCF of wheat straw with 7% WIS showing glucose (●), xylose (■), xylitol (□) and ethanol (▲). A: TMB3424 (native XR). B: TMB3422 (mutated XR). C: TMB3426 (native XR + Gxf1). D: TMB3425 (mutated XR + Gxf1).

Table 3.

Summary of SSCF of wheat straw with 7% WIS after 96 h showing concentrations and yields (mean values of duplicate experiments). The same conditions (temperature, pH, yeast- and enzyme loading) were used in all experiments.

XR and Gxf1 expression
(Strain)		 Xylose
(g L-1)		 Xylitol
(g L-1)		 Glycerol
(g L-1)		 Ethanol
(g L-1)		 Xylose consumptiona
(%)		 Xylitol yieldb
(%)		 Ethanol yieldc
(g g-1)
Native XR
(TMB3424)		 12.7 ± 0.9 2.5 ± 0.3 4.4 ± 0.1 22.2 ± 0.1 38 32 0.33
Mutated XR
(TMB3422)		 5.0 ± 0.6 2.1 ± 0.1 3.9 ± 0.3 26.2 ± 0.4 76 13 0.39
Native XR+Gxf1
(TMB3426)		 11.8 ± 2.0 2.7 ± 0.8 4.1 ± 0.2 20.1 ± 0.1 42 31 0.30
Mutated XR+Gxf1
(TMB3425)		 3.2 ± 0.5 2.4 ± 0.1 4.2 ± 0.1 25.9 ± 0.9 84 13 0.39
Open in a new tab

a. Based on to total amount of xylose (present both in the fibers and the liquid fraction).

b. Based on consumed xylose.

c. Based on total amount of available sugars (present both in the fibers and the liquid fraction).

When the native XR was replaced by mXR the xylose consumption was almost doubled from 38% to 76% (Table 3; Figure 1A and 1B). Additionally, the xylitol yield was reduced from 32% to 13%, which resulted in a 20% increased ethanol yield of 0.39 and a final ethanol concentration of 26.2 g L-1 (Table 3). In the isogenic strain background the significantly improved ethanolic xylose fermentation directly reflects the difference between the kinetic properties of the native and the mutated XR (Runquist et al. 2010a). Both Vmax and the NADH/NADPH utilization ratio for mXR are an order of magnitude higher than for the native XR, which in SSCF translate to faster xylose utilization and significantly less xylitol secretion.

In contrast to the influence of mXR on xylose consumption and ethanol production the introduction of the glucose/xylose facilitator Gxf1 only marginally influenced SSCF of pretreated wheat straw (Figure 1A and 1C; Table 3). The small increase in xylose consumption observed in comparison to the control strain was not statistically significant, and the same applies for the changes in ethanol and xylitol yields.

The rather limited influence of Gxf1 when the currently used strain background was assessed in ethanolic xylose fermentation in SSCF was further demonstrated when mXR and Gxf1 were both introduced in the same strain. The mXR/Gxf1 strain displayed a substrate-consumption/product-formation pattern very similar to the mXR strain (Figure 1B and 1D). Again a slight increase in xylose consumption was observed, from 76 to 84% (Table 3). However, the final ethanol concentration, as well as the ethanol and xylitol yield, was the same as for the mXR strain.

Discussion

The glucose/xylose facilitator Gxf1 from C. intermedia (Leandro et al. 2008) has been shown to increase xylose uptake and aerobic growth at low sugar concentrations in an laboratory xylose-utilizing CEN.PK strain (Runquist et al. 2009) as well as in the industrial xylose-utilizing TMB3400 strain (Fonseca et al. submitted). Similarly, the presence of the mutated (N272D) xylose reductase (mXR) from P. stipitis, increased xylose uptake and anaerobic growth (Runquist et al. 2010a) in synthetic medium. In addition, mXR shifted product formation from xylitol to ethanol. The current comparison using isogenic S. cerevisiae CEN.PK strains was undertaken to elucidate the relative contribution of these two beneficial genetic modifications on xylose consumption and ethanol and clarify if these genetic traits could act synergistically. Simultaneous saccharification and co-fermentation (SSCF) (Olofsson et al. 2008a) of non-detoxified pretreated wheat straw was chosen as experimental model, since it is an industrial medium, interesting for commercial ethanol production scale. Our investigation showed that in the CEN.PK strain background and in the SSCF set-up, mXR had a far greater influence on xylose consumption and product formation than Gxf1. The presence of mXR doubled the xylose uptake, decreased the xylitol yield by half and as a result increased the obtained ethanol yield in SSCF by about 20%. In contrast, Gxf1 at most increased the xylose uptake by 10% irrespective of the presence of XR and mXR, receptively.

SSF (simultaneous saccharification and fermentation), the forerunner of SSCF was originally designed as a means to generate low glucose concentration in the reactor to overcome glucose inhibition of cellulose hydrolysis (Takagi et al. 1977). It was later observed that this set-up also favored co-utilization of xylose when recombinant xylose-utilizing strains of S. cerevisiae were used (Olofsson et al. 2008b; Öhgren et al. 2006). In SSCF, the fermenting yeast is exposed to a high xylose/glucose ratio since the hemicellulose fraction is primarily hydrolyzed in the acid-pretreatment step (Olofsson et al. 2008a) while glucose is continuously released throughout the enzymatic hydrolysis. Enhanced co-utilization of xylose and glucose in SSCF is in accordance with numerous independent observations, which demonstrated that glucose in fact enhances xylose utilization at low but non-zero concentrations (Meinander et al. 1999; Pitkänen et al. 2003; Krahulec et al. 2010). This has been attributed both to activation of the enzymes of the lower glycolytic pathway (Boles et al. 1996), and to improved co-factor regeneration (Pitkänen et al. 2003). In addition the low glucose concentration in SSCF favors induction of high affinity hexose transporters, which also display high affinity for xylose (Pitkänen et al. 2003; Bertilsson et al. 2008). Therefore the fact that xylose uptake only increased by 10% in the Gxf1 strains may not only reflect the properties of the transporter, but may also result from the SSCF conditions.

When the Gxf1 transporter was expressed in the industrial S. cerevisiae strain TMB3400 and assessed in SSCF of acid-pretreated wheat straw similar to the current experimental set-up, the xylose uptake also increased by about 10% (Fonseca et al. submitted). The additional xylose taken up was stoichiometrically converted to xylitol and glycerol. Metabolic flux analysis (MFA) suggested that the presence of Gxf1 shifted the control of xylose catabolism from transport to down-stream catabolic reactions. The mXR mutant has a higher Vmax and higher NADH/NAPH selectivity ratio, which was shown to directly relate to increased anaerobic xylose growth and increased ethanol formation (Bengtsson et al. 2009; Runquist et al. 2010a). The current study was set up to investigate whether the presence of mXR would shift the control of xylose catabolism to transport. However, the results show that xylose catabolism downstream of transport still dictated the metabolic flux, and that an even faster xylose catabolism would be required to fully benefit from the increased xylose transport capacity. The presence of only Gxf1 resulted in slightly higher xylose consumption, which was not converted to ethanol. Instead somewhat less ethanol was produced, which was not seen when mXR was also expressed. This may reflect that transport exercises a slightly higher control in the strain harboring mXR because mXR has significantly higher activity than XR (Runquist et al. 2010a) which is in accordance with previous reports showing that transport becomes more controlling at higher XR activity (Gárdonyi et al. 2003).

During pretreatment and hydrolysis a spectrum of compounds that inhibit the cellular metabolism are released and formed and many of these compounds inhibit ethanolic fermentation (Almeida et al. 2007). S. cerevisiae strains with an industrial background are generally more inhibitor tolerant than haploid laboratory strains (Almeida et al. 2007). The haploid CEN.PK strain background was chosen in the current study to generate isogenic strains that permitted the assessment of the relative contribution of mXR and Gxf1, respectively, to ethanolic xylose fermentation in SSCF of pretreated wheat straw. The control strain carrying the native XR consumed 38% of the available xylose, whereas the mXR strain converted twice as much in the non-detoxified wheat straw. The conversion obtained with the mXR strain in fact compared well to that reported for the industrial XR/XDH based xylose fermenting strain TMB3400 in SSCF of pretreated wheat straw of a similar composition (Olofsson et al. 2008b).

Among the inhibitory compounds formed during pretreatment and hydrolysis, there are several which act as electron acceptors (Almeida et al. 2007). Such compounds have been shown to function as "redox sinks" able to alleviate the redox imbalance caused by the difference in cofactor preference of XR and XDH (Wahlbom and Hahn-Hägerdal 2002). This has been shown to reduce the xylitol yield in non-detoxified hydrolyzate with as much as three times in model SSF experiments compared to defined media (Olofsson et al. 2008b). For the mXR strain xylitol formation was reduced about 50% from 0.24 to 0.13 g g-1 when compared with xylose fermentation in defined medium (Runquist et al. 2010a).

In conclusion, the current work investigated targeted metabolic changes for improved xylose fermentation in SSCF of undetoxified pretreated wheat straw. These kinds of investigations are important since strain-improvements are often considerably less pronounced in lignocellulosic hydrolyzates under process-like conditions. Due to the mutated XR the xylose uptake could be doubled along with a significant reduced xylitol yield, resulting in a substantial increase in the ethanol yield. It will be important to increase the final ethanol concentration further by increasing the WIS-content with a maintained ethanol yield for the economic viability of the process (Galbe et al. 2007). This is likely to require a combination of further strain development and improved process technology.

Competing interests

BHH is co-founder and chairman of the board of C5 Ligno Technologies in Lund AB.

Authors' contributions

KO participated in the design of the study, performed the experimental work and wrote the manuscript. DR participated in the design of the study, constructed the strains and commented on the manuscript. GL and BHH participated in the design of the study and commented on the manuscript. All authors contributed to the scientific discussion throughout the work and have read and approved the final manuscript.

Contributor Information

Kim Olofsson, Email: gunagenomics@gmail.com.

David Runquist, Email: gunagenomics@gmail.com.

Bärbel Hahn-Hägerdal, Email: gunagenomics@gmail.com.

Gunnar Lidén, Email: gunnar.liden@chemeng.lth.se.

Acknowledgements

The Swedish Energy Agency is gratefully acknowledged for financial support.

References

  1. Adney B, Baker J. Measurement of Cellulase Activities (LAP) NREL, Golden, CO; 1996. [Google Scholar]
  2. Alkasrawi M, Rudolf A, Lidén G. Influence of strain and cultivation procedure on the performance of simultaneous saccharification and fermentation of steam pretreated spruce. Enzyme Microb Technol. 2006;38(1-2):279–287. [Google Scholar]
  3. Almeida JRM, Modig T, Petersson A, Hahn-Hägerdal B, Lidén G, Gorwa-Grauslund MF. Increased tolerance and conversion of inhibitors in lignocellulosic hydrolysates by Saccharomyces cerevisiae. J Chem Tech Biotechnol. 2007;82(4):340–349. doi: 10.1002/jctb.1676. [DOI] [Google Scholar]
  4. Bengtsson O, Hahn-Hägerdal B, Gorwa-Grauslund M. Xylose reductase from Pichia stipitis with altered coenzyme preference improves ethanolic xylose fermentation by recombinant Saccharomyces cerevisiae. Biotechnol Biofuels. 2009;2(1):9. doi: 10.1186/1754-6834-2-9. [DOI] [PMC free article] [PubMed] [Google Scholar]
  5. Berghem LER, Pettersson LG. The mechanism of enzymatic cellulose degradation. Eur J Biochem. 1973;37(1):21–30. doi: 10.1111/j.1432-1033.1973.tb02952.x. [DOI] [PubMed] [Google Scholar]
  6. Bertilsson M, Andersson J, Lidén G. Modeling simultaneous glucose and xylose uptake in Saccharomyces cerevisiae from kinetics and gene expression of sugar transporters. Bioprocess Biosyst Eng. 2008;31:369–377. doi: 10.1007/s00449-007-0169-1. [DOI] [PubMed] [Google Scholar]
  7. Boles E, Müller S, Zimmermann FK. A multi-layered sensory system controls yeast glycolytic gene expression. Mol Microbiol. 1996;19:641–642. doi: 10.1046/j.1365-2958.1996.t01-1-442924.x. [DOI] [PubMed] [Google Scholar]
  8. Bruinenberg PM, Bot PHM, Dijken JP, Scheffers WA. The role of redox balances in the anaerobic fermentation of xylose by yeasts. Appl Microbiol Biotechnol. 1983;18(5):287–292. doi: 10.1007/BF00500493. [DOI] [Google Scholar]
  9. Galbe M, Sassner P, Wingren A, Zacchi G. In: Biofuels, Advances in Biochemical Engineering/Biotechnology. Olsson L, editor. Vol. 108. Springer Berlin/Heidelberg; 2007. Process engineering economics of bioethanol production; pp. 303–327. full_text. [DOI] [PubMed] [Google Scholar]
  10. Gárdonyi M, Jeppsson M, Liden G, Gorwa-Grauslund MF, Hahn-Hägerdal B. Control of xylose consumption by xylose transport in recombinant Saccharomyces cerevisiae. Biotechnol Bioeng. 2003;82(7):818–824. doi: 10.1002/bit.10631. [DOI] [PubMed] [Google Scholar]
  11. Gietz R, Sugino A. New yeast - Escherichia coli shuttle vectors constructed with in vitro mutagenized yeast genes lacking six-base pair restriction sites. Gene. 1988;74(2):527–534. doi: 10.1016/0378-1119(88)90185-0. [DOI] [PubMed] [Google Scholar]
  12. Gietz RD, Schiestl RH, Willems AR, Woods RA. Studies on the transformation of intact yeast cells by the LiAc/SS-DNA/PEG procedure. Yeast. 1995;11(4):355–360. doi: 10.1002/yea.320110408. [DOI] [PubMed] [Google Scholar]
  13. Hahn-Hägerdal B, Karhumaa K, Jeppsson M, Gorwa-Grauslund M. Metabolic engineering for pentose utilization in Saccharomyces cerevisiae. Adv Biochem Eng Biotechnol. 2007;108:147–177. doi: 10.1007/10_2007_062. [DOI] [PubMed] [Google Scholar]
  14. Hamacher T, Becker J, Gárdonyi M, Hahn-Hägerdal B, Boles E. Characterization of the xylose-transporting properties of yeast hexose transporters and their influence on xylose utilization. Microbiology. 2002;148(Pt-9):2783–2788. doi: 10.1099/00221287-148-9-2783. [DOI] [PubMed] [Google Scholar]
  15. Hector R, Qureshi N, Hughes S, Cotta M. Expression of a heterologous xylose transporter in a Saccharomyces cerevisiae strain engineered to utilize xylose improves aerobic xylose consumption. Appl Microbiol Biotechnol. 2008;80(4):675–684. doi: 10.1007/s00253-008-1583-2. [DOI] [PubMed] [Google Scholar]
  16. Karhumaa K, Hahn-Hägerdal B, Gorwa-Grauslund MF. Investigation of limiting metabolic steps in the utilization of xylose by recombinant Saccharomyces cerevisiae using metabolic engineering. Yeast. 2005;22(5):359–368. doi: 10.1002/yea.1216. [DOI] [PubMed] [Google Scholar]
  17. Katahira S, Ito M, Takema H, Fujita Y, Tanino T, Tanaka T, Fukuda H, Kondo A. Improvement of ethanol productivity during xylose and glucose co-fermentation by xylose-assimilating S. cerevisiae via expression of glucose transporter Sut1. Enzyme Microb Technol. 2008;43(2):115–119. doi: 10.1016/j.enzmictec.2008.03.001. [DOI] [Google Scholar]
  18. Kilian SG, Uden N. Transport of xylose and glucose in the xylose-fermenting yeast Pichia stipitis. Appl Microbiol Biotechnol. 1988;27(5):545–548. [Google Scholar]
  19. Krahulec S, Petschacher B, Wallner M, Longus K, Klimacek M, Nidetzky B. Fermentation of mixed glucose-xylose substrates by engineered strains of Saccharomyces cerevisiae: role of the coenzyme specificity of xylose reductase, and effect of glucose on xylose utilization. Microb Cell Fact. 2010;9(1):16. doi: 10.1186/1475-2859-9-16. [DOI] [PMC free article] [PubMed] [Google Scholar]
  20. Kötter P, Ciriacy M. Xylose fermentation by Saccharomyces cerevisiae. Appl Microbiol Biotechnol. 1993;38(6):776–783. doi: 10.1007/BF00167144. [DOI] [Google Scholar]
  21. Leandro MJ, Gonçalves P, Spencer-Martins I. Two glucose/xylose transporter genes from the yeast Candida intermedia: first molecular characterization of a yeast xylose-H+ symporter. Biochem J. 2006;395:543–549. doi: 10.1042/BJ20051465. [DOI] [PMC free article] [PubMed] [Google Scholar]
  22. Leandro MJ, Spencer-Martins I, Goncalves P. The expression in Saccharomyces cerevisiae of a glucose/xylose symporter from Candida intermedia is affected by the presence of a glucose/xylose facilitator. Microbiology. 2008;154(6):1646–1655. doi: 10.1099/mic.0.2007/015511-0. [DOI] [PubMed] [Google Scholar]
  23. Matsushika A, Inoue H, Kodaki T, Sawayama S. Ethanol production from xylose in engineered Saccharomyces cerevisiae strains: current state and perspectives. Appl Microbiol Biotechnol. 2009;84(1):37–53. doi: 10.1007/s00253-009-2101-x. [DOI] [PubMed] [Google Scholar]
  24. Meinander NQ, Boels I, Hahn-Hägerdal B. Fermentation of xylose/glucose mixtures by metabolically engineered Saccharomyces cerevisiae strains expressing XYL1 and XYL2 from Pichia stipitis with and without overexpression of TAL1. Bioresour Technol. 1999;68(1):79–87. doi: 10.1016/S0960-8524(98)00085-6. [DOI] [Google Scholar]
  25. Meinander NQ, Hahn-Hägerdal B. Influence of cosubstrate concentration on xylose conversion by recombinant, XYL1-expressing Saccharomyces cerevisiae: a comparison of different sugars and ethanol as cosubstrates. Appl Environ Microbiol. 1997;63(5):1959–1964. doi: 10.1128/aem.63.5.1959-1964.1997. [DOI] [PMC free article] [PubMed] [Google Scholar]
  26. Olofsson K, Bertilsson M, Lidén G. A short review on SSF - an interesting process option for ethanol production from lignocellulosic feedstocks. Biotechnol Biofuels. 2008;1(7) doi: 10.1186/1754-6834-1-7. [DOI] [PMC free article] [PubMed] [Google Scholar]
  27. Olofsson K, Palmqvist B, Liden G. Improving simultaneous saccharification and co-fermentation of pretreated wheat straw using both enzyme and substrate feeding. Biotechnol Biofuels. 2010;3(1):17. doi: 10.1186/1754-6834-3-17. [DOI] [PMC free article] [PubMed] [Google Scholar]
  28. Olofsson K, Rudolf A, Lidén G. Designing simultaneous saccharification and fermentation for improved xylose conversion by a recombinant strain of Saccharomyces cerevisiae. J Biotechnol. 2008;134:112–120. doi: 10.1016/j.jbiotec.2008.01.004. [DOI] [PubMed] [Google Scholar]
  29. Palmqvist E, Hahn-Hägerdal B, Galbe M, Larsson M, Stenberg K, Szengyel Z, Tengborg C, Zacchi G. Design and operation of a bench-scale process development unit for the production of ethanol from lignocellulosics. Bioresour Technol. 1996;58(2):171–179. doi: 10.1016/S0960-8524(96)00096-X. [DOI] [Google Scholar]
  30. Pitkänen J-P, Aristidou A, Salusjärvi L, Ruohonen L, Penttilä M. Metabolic flux analysis of xylose metabolism in recombinant Saccharomyces cerevisiae using continuous culture. Metab Eng. 2003;5(1):16–31. doi: 10.1016/S1096-7176(02)00012-5. [DOI] [PubMed] [Google Scholar]
  31. Runquist D, Fonseca C, Rådström P, Spencer-Martins I, Hahn-Hägerdal B. Expression of the Gxf1 transporter from Candida intermedia improves fermentation performance in recombinant xylose-utilizing Saccharomyces cerevisiae. Appl Microbiol Biotechnol. 2009;82(1):123–130. doi: 10.1007/s00253-008-1773-y. [DOI] [PubMed] [Google Scholar]
  32. Runquist D, Hahn-Hagerdal B, Bettiga M. A randomly mutagenized xylose reductase increases the ethanol productivity in xylose-utilizing Saccharomyces cerevisiae. Appl Environ Microbiol. 2010;76(23):7796–7802. doi: 10.1128/AEM.01505-10. [DOI] [PMC free article] [PubMed] [Google Scholar]
  33. Runquist D, Hahn-Hagerdal B, Radstrom P. Comparison of heterologous xylose transporters in recombinant Saccharomyces cerevisiae. Biotechnol Biofuels. 2010;3(1):5. doi: 10.1186/1754-6834-3-5. [DOI] [PMC free article] [PubMed] [Google Scholar]
  34. Saloheimo A, Rauta J, Stasyk O, Sibirny A, Penttilä M, Ruohonen L. Xylose transport studies with xylose-utilizing Saccharomyces cerevisiae strains expressing heterologous and homologous permeases. Appl Microbiol Biotechnol. 2007;74(5):1041–1052. doi: 10.1007/s00253-006-0747-1. [DOI] [PubMed] [Google Scholar]
  35. Sambrook J, Fritsch EF, Maniatis T. Molecular cloning: a laboratory manual. Cold Spring Harbor Laboratory Press, Cold Spring Harbor, NY, USA; 1989. [Google Scholar]
  36. Sluiter A, Hames B, Ruiz R, Scarlata C, Sluiter J, Templeton D. Determination of sugars, byproducts, and degradation products in liquid fraction process samples(LAP) NREL, Golden, CO; 2008. [Google Scholar]
  37. Sluiter A, Hames B, Ruiz R, Scarlata C, Sluiter J, Templeton D, Crocker D. Determination of structural carbohydrates and lignin in biomass(LAP) NREL, Golden, CO; 2008. [Google Scholar]
  38. Taherzadeh MJ, Lidén G, Gustafsson L, Niklasson C. The effects of pantothenate deficiency and acetate addition on anaerobic batch fermentation of glucose by Saccharomyces cerevisiae. Appl Microbiol Biotechnol. 1996;46(2):176–182. doi: 10.1007/s002530050801. [DOI] [PubMed] [Google Scholar]
  39. Takagi M, Abe S, Suzuki S, Emert GH, Yata N. In: Bioconversion Symposium, New Delhi, India. Ghose TK, editor. 1977. A method for production of alcohol directly from cellulose using cellulase and yeast; pp. 551–571. [Google Scholar]
  40. Wahlbom CF, Hahn-Hägerdal B. Furfural, 5-hydroxymethyl furfural, and acetoin act as external electron acceptors during anaerobic fermentation of xylose in recombinant Saccharomyces cerevisiae. Biotechnol Bioeng. 2002;78(2):172–178. doi: 10.1002/bit.10188. [DOI] [PubMed] [Google Scholar]
  41. Van Vleet JH, Jeffries TW. Yeast metabolic engineering for hemicellulosic ethanol production. Curr Opin Biotechnol. 2009;20(3):300–306. doi: 10.1016/j.copbio.2009.06.001. [DOI] [PubMed] [Google Scholar]
  42. Watanabe S, Abu Saleh A, Pack SP, Annaluru N, Kodaki T, Makino K. Ethanol production from xylose by recombinant Saccharomyces cerevisiae expressing protein-engineered NADH-preferring xylose reductase from Pichia stipitis. Microbiology. 2007;153(9):3044–3054. doi: 10.1099/mic.0.2007/007856-0. [DOI] [PubMed] [Google Scholar]
  43. Wingren A, Galbe M, Zacchi G. Techno-economic evaluation of producing ethanol from softwood: Comparison of SSF and SHF and identification of bottlenecks. Biotechnol Prog. 2003;19(4):1109–1117. doi: 10.1021/bp0340180. [DOI] [PubMed] [Google Scholar]
  44. Öhgren K, Bengtsson O, Gorwa-Grauslund MF, Galbe M, Hahn-Hägerdal B, Zacchi G. Simultaneous saccharification and co-fermentation of glucose and xylose in steam-pretreated corn stover at high fiber content with Saccharomyces cerevisiae TMB3400. J Biotechnol. 2006;126(4):488–498. doi: 10.1016/j.jbiotec.2006.05.001. [DOI] [PubMed] [Google Scholar]

Articles from AMB Express are provided here courtesy of Springer-Verlag

RESOURCES