Skip to main content
PMC home page
Cytotechnology logoLink to Cytotechnology
. 1998 Nov;28(1-3):213–227. doi: 10.1023/A:1008010605287

Effects of CO2 and osmolality on hybridoma cells: growth, metabolism and monoclonal antibody production

Vivian M deZengotita 1, Roy Kimura 1, William M Miller 1,✉
PMCID: PMC3449846  PMID: 19003422

Abstract

CO2 partial pressure (pCO2) in industrial cell culture reactors may reach 150–200 mm Hg, which can significantly inhibit cell growth and recombinant protein production. Due to equilibrium with bicarbonate, increased pCO2 at constant pH results in a proportional increase in osmolality. Hybridoma AB2-143.2 cell growth rate decreased with increasing pCO2 in well-plate culture, with a 45% decrease at 195 mm Hg with partial osmolality compensation (to 361 mOsm kg- 1). Inhibition was more extensive without osmolality compensation, with a 63% decrease in growth rate at 195 mm Hg and 415 mOsm kg-1. Also, the hybridoma death rate increased with increasing pCO2, with 31- and 64-fold increases at 250 mm Hg pCO2 for 401 and 469 mOsm kg- 1, respectively. The specific glucose consumption and lactate production rates were 40–50% lower at 140 mm Hg pCO2. However, there was little further inhibition of glycolysis at higher pCO2. The specific antibody production rate was not significantly affected by pCO2 or osmolality within the range tested. Hybridomas were also exposed to elevated pCO2 in continuous culture. The viable cell density decreased by 25–40% at 140 mm Hg. In contrast to the well-plate cultures, the death rate was lower at the new steady state at 140 mm Hg. This was probably due to higher residual nutrient and lower byproduct levels at the lower cell density (at the same dilution rate), and was associated with increased cell-specific glucose and oxygen uptake. Thus, the apparent effects of pCO2 may vary with the culture system.

Keywords: antibody production, carbon dioxide, cell metabolism, continuous culture, inhibition

Full Text

The Full Text of this article is available as a PDF (141.1 KB).

Footnotes

VMdZ and RK contributed equally to the results in this article.

References

  1. Altman PL and Dittmer DS (1971) Respiration and circulation. Federation of American Societies of Experimental Biology, MD.
  2. Aunins JG, Henzler H-J. Aeration in Cell Culture Bioreactors. In: Stephanopoulos G, Rehm H-J, Reed G, Puhler A, Stadler PJW, editors. Biotechnology: A Multi-volume Comprehensive Treatise (Vol. 3), Bioprocessing. Weinheim, Germany: VCH Verlag; 1993. [Google Scholar]
  3. Aunins JG, Glazomitsky K and Buckland B (1993) Animal Cell Culture Reactor Design: Known and Unknown. In: Proceedings of 3rd Intl. Conference on Bioreactor and Bioprocess Fluid Dynamics, Kluwer Academic Publishers, p. 175.
  4. Drapeau D, Luan Y-T, Whiteford JC, Lavin DP and Adamson SR (1990) Cell culture scale-up in stirred tank reactors. Presented at The Annual Meeting of the Society of Industrial Microbiology, Orlando, FL.
  5. England BK, Chastain JL, Mitch WE. Abnormalities in protein synthesis and degradation induced by extracellular pH in BC3H1 myocytes. Am J Physiol. 1991;260:C277–C282. doi: 10.1152/ajpcell.1991.260.2.C277. [DOI] [PubMed] [Google Scholar]
  6. Garnier A, Voyer R, Tom R, Perret S, Jardin B, Kamen A. Dissolved carbon dioxide accumulation in a large scale and high density production of TGFβreceptor with baculovirus infected Sf-9 cells. Cytotechnology. 1996;22:53–63. doi: 10.1007/BF00353924. [DOI] [PubMed] [Google Scholar]
  7. Glantz SA. Primer of biostatistics. New York: McGraw-Hill; 1981. [Google Scholar]
  8. Gray DR, Chen S, Howarth W, Inlow D, Maiorella BL. Carbon dioxide in large-scale and high density CHO cell perfusion culture. Cytotechnology. 1996;22:65–78. doi: 10.1007/BF00353925. [DOI] [PubMed] [Google Scholar]
  9. Hornbeck PV, Lewis GK. Idiotype connectance in the immune system. II. A heavy chain variable region idiotype that dominates the antibody response to the p-azobenzenearsonate group is a minor idiotype in the response to trinitrophenyl group. J Exp Med. 1985;161:53–71. doi: 10.1084/jem.161.1.53. [DOI] [PMC free article] [PubMed] [Google Scholar]
  10. Kimura, R (1996) Effects of elevated carbon dioxide partial pressure on recombinant Chinese hamster ovary and hybridoma cell cultures. PhD Dissertation, Northwestern University.
  11. Kimura R, Miller WM. Effects of elevated pCO2 and/or osmolality on the growth and recombinant tPA production of CHO Cells. Biotechnol Bioeng. 1996;52:152–160. doi: 10.1002/(SICI)1097-0290(19961005)52:1<152::AID-BIT15>3.0.CO;2-Q. [DOI] [PubMed] [Google Scholar]
  12. Krapf R, Berry CA, Alpern RJ, Rector FC., Jr Regulation of cell pH by ambient bicarbonate, carbon dioxide tension, and pH in the rabbit proximal convoluted tubule. J Clin Invest. 1988;81:381–389. doi: 10.1172/JCI113330. [DOI] [PMC free article] [PubMed] [Google Scholar]
  13. Kurano N, Leist C, Messi F, Kurano S, Fiechter A. Growth behavior of Chinese Hamster Ovary cells in a compact loop bioreactor: 1. Effects of physical and chemical environments. J Biotechnol. 1990;15:101–112. doi: 10.1016/0168-1656(90)90054-F. [DOI] [PubMed] [Google Scholar]
  14. Lovrecz G, Gray P. Use of on-line analysis to monitor recombinant mammalian cell cultures. Cytotechnology. 1994;14:167–175. doi: 10.1007/BF00749613. [DOI] [PubMed] [Google Scholar]
  15. Madshus IH. Regulation of intracellular pH in eukaryotic cells (Review Article) Biochem J. 1988;250:1–8. doi: 10.1042/bj2500001. [DOI] [PMC free article] [PubMed] [Google Scholar]
  16. Mellergård P, Ouyang Y, Siesjö BK. Intracellular pH regulation in cultured rat astrocytes in CO2/HCO-3-containing media. Exp Brain Res. 1993;95:371–380. doi: 10.1007/BF00227129. [DOI] [PubMed] [Google Scholar]
  17. Miller WM, Blanch HW. Regulation of Animal Cell Metabolism in Bioreactors. In: Ho CS, Wang DIC, editors. Animal Cell Reactors. Stoneham, MA: Butterworth-Heinemann; 1991. [Google Scholar]
  18. Miller WM, Blanch HW, Wilke CR. A kinetic analysis of hybridoma growth and metabolism in batch and continuous culture: Effect of nutrient concentration, dilution rate, and pH. Biotechnol Bioeng. 1988;32:947–965. doi: 10.1002/bit.260320803. [DOI] [PubMed] [Google Scholar]
  19. Ozturk SS, Palsson BO. Effect of medium osmolarity on hybridoma growth, metabolism, and antibody production. Biotechnol Bioeng. 1991;37:989–993. doi: 10.1002/bit.260371015. [DOI] [PubMed] [Google Scholar]
  20. Putnam RW, Grubbs RD. Steady-state pHi, buffering power, and effect of CO2 in a smooth muscle-like cell line. Am J Physiol. 1990;258:C461–C469. doi: 10.1152/ajpcell.1990.258.3.C461. [DOI] [PubMed] [Google Scholar]
  21. Reddy S, Miller WM. Effects of abrupt and gradual osmotic stress on antibody production and content in hybridoma cells that differ in production kinetics. Biotechnol Prog. 1994;10:165–173. doi: 10.1021/bp00026a006. [DOI] [PubMed] [Google Scholar]
  22. Royce PNC, Thornhill NF. Estimation of dissolved carbon dioxide concentrations in aerobic fermentations. AIChE J. 1991;37:1680–1686. doi: 10.1002/aic.690371111. [DOI] [Google Scholar]
  23. Simchowitz L, Roos A. Regulation of intracellular pH in human neutrophils. J Gen Physiol. 1985;85:443–470. doi: 10.1085/jgp.85.3.443. [DOI] [PMC free article] [PubMed] [Google Scholar]
  24. Taticek R, Petersen S, Konstantinov K and Naveh D (1998) Effect of dissolved carbon dioxide and bicarbonate on mammalian cell metabolism and recombinant protein productivity in high density perfusion culture. Presented at Cell Culture Engineering VI, San Diego, CA.
  25. Thomas RC. Bicarbonate briefly CO2-free. Nature. 1995;374:597–598. doi: 10.1038/374597a0. [DOI] [PubMed] [Google Scholar]
  26. Zupke C and Green J (1998) Modeling of CO2 concentration in small and large scale bioreactors. Presented at Cell Culture Engineering VI, San Diego, CA.

Articles from Cytotechnology are provided here courtesy of Springer Science+Business Media B.V.

RESOURCES