Skip to main content
PMC home page
Toxins logoLink to Toxins
. 2013 Dec 23;6(1):20–32. doi: 10.3390/toxins6010020

Incidence and Levels of Deoxynivalenol, Fumonisins and Zearalenone Contaminants in Animal Feeds Used in Korea in 2012

Dong-Ho Kim 1, In-Hye Lee 2, Woo-Hyun Do 2, Woo-Seon Nam 2, Hua Li 2, Han-Sub Jang 2, Chan Lee 2,*
PMCID: PMC3920247  PMID: 24366207

Abstract

The objective of this study was to evaluate the occurrence and levels of deoxynivalenol (DON), fumonisins B1 and B2 (FBs), and zearalenone (ZEN) contaminants in animal feeds used in Korea in 2012. Contamination with DON was observed in 91.33% and 53.33% in compound feeds and feed ingredients, respectively. Among compound feeds, poultry layer feed (laying) exhibited the highest contaminant level of 1.492 mg/kg. FBs contaminants were present in compound feeds and feed ingredients at 93.33% and 83.33%, respectively. Most poultry broiler (early) feeds were highly contaminated with FBs, and one of these feeds detected the level as 12.823 mg/kg as the highest level. The levels of ZEN in compound feeds and feed ingredients were 71.33% and 47%, respectively. Ninety-eight percent of compound feeds for cattle were contaminated with ZEN, and the highest contamination level of 0.405 mg/kg was observed in cattle fatting feeds.

Keywords: Fusarium, deoxynivalenol, fumonisin B1, fumonisin B2, zearalenone, compound feeds, feed ingredients

1. Introduction

Members of the mycotoxin-producing fungal species, Fusarium, occur as facultative saprophytes and parasites. They are widespread in nature, and frequently contaminate many crops (corn, wheat, rye, oats, and rice) by producing a wide range of toxins [1]. The most hazardous Fusarium mycotoxins, in terms of animal health and productivity, are deoxynivalenol (DON), zearalenone (ZEN), fumonisins (FBs) and moniliformin [2].

DON, which is produced by F. graminearum [3] and F. culmorum [4], is one of the most common contaminants of corn, wheat, and barley worldwide. DON was characterized as a trichothecene and was given the name “vomitoxin” because of its emetic effect on swine [5,6]. FBs, which are diesters of propane-1,2,3-tricarboylic acid and various 2-amino-12,16-dimetylpolyhydroxyeicosanes, are natural contaminants in maize and maize-based feeds and foods worldwide. FBs such as FB1, FB2, and FB3 are particularly produced by F. verticillioides, and the related F. proliferatum [7]. FBs are commonly detected in foodstuffs such as corn, sorghum, asparagus, rice, beer, and beans. In long-term feeding studies, purified FB1 caused liver and kidney tumors in rodents [8]. ZEN is one of the most widely distributed mycotoxins produced by the Fusarium species F. graminearum and F. culmorum. It is found worldwide in various cereals such as maize, barley, wheat, and sorghum, and is classified as an estrogenic mycotoxin because it frequently uses hyperestrogenic syndrome in animals. ZEN-contaminated feed or grain, when consumed by livestock, can contribute to a wide variety of reproductive problems.

The presence of mycotoxins in grains and animal feeds has been reported worldwide for decades. Mycotoxin contamination of feed has become a major concern in animal feed science because it can cause acute or chronic mycotoxicosis in animals [9]. For these reasons, the regulation of mycotoxin levels in feed is of great interest, and the commission regulation of the European community set maximum levels (MLs) for FBs, DON, and ZEN in various animal feeds in 2007. Some countries in Asia, for example China and Japan, also have guidelines for these toxins in feeds. The MLs for FBs for complete feed in China was set to 0.500 mg/kg, 0.500 mg/kg for DON, and 0.100 mg/kg for ZEN. However, there are still no guideline values for these toxins in animal feed in Korea. This study therefore aimed to assess the occurrence and levels of DON, FBs, and ZEN in animal feeds distributed in South Korea in 2012, to better understand the contamination levels of mycotoxins in feeds.

2. Results and Discussion

Contamination Levels

Contamination Levels of DON in Compound Feeds and Feed Ingredients

As shown in Table 1, 100% of the cattle feed samples were contaminated with DON, with the levels of contamination ranging from 0.131 to 1.000 mg/kg. In swine feed, 44 out of 50 samples (88%) were contaminated with DON, with levels of 0.037–0.982 mg/kg, and a mean contamination level of 0.297 mg/kg. The fatting growing (early) feed was contaminated with the highest levels of DON out of the swine feed samples. Eighty-six percent of the poultry feed samples were contaminated with DON, and the levels of contamination ranged from 0.035 to 1.492 mg/kg, which was lower than that listed by commission regulation of the European Community. Consistent with these observations, Labuda et al. (2005) reported that 56% of poultry feed samples were contaminated with DON, and that the levels of contamination ranged from 0.064 to 1.230 mg/kg, with a mean of 0.303 mg/kg [10].

Table 1.

The presence of deoxynivalenol (DON) in compound feeds and feed ingredients.

Samples Number (%) of DON contaminated samples Concentration (mg/kg)
Type Total number Contaminated number Minimum ± SD Maximum ± SD Mean ± SD
Cattle feeds
Breeding Pregnancy 5 5 (100b) 0.225 ± 0.030 0.869 ± 0.004 0.463 ± 0.248
Lactation Lactation 11 11 (100b) 0.131 ± 0.027 1.000 ± 0.084 0.466 ± 0.280
Calf 11 11 (100b) 0.137 ± 0.018 0.942 ± 0.066 0.465 ± 0.280
Fatting Calves 11 11 (100b) 0.182 ± 0.002 0.943 ± 0.148 0.585 ± 0.282
Finishing (earlyc) 6 6 (100b) 0.213 ± 0.008 0.818 ± 0.181 0.470 ± 0.256
Finishing (lated) 6 6 (100b) 0.187 ± 0.036 0.885 ± 0.030 0.642 ± 0.334
Total 50 50 (100b)
Swine feeds
Piglets 5 2 (40b) 0.046 ± 0.002 0.116 ± 0.020 0.081 ± 0.049
Piglets ≥ 5 kg 10 10 (100b) 0.114 ± 0.011 0.781 ± 0.038 0.325 ± 0.223
Breeding Pregnancy 10 10 (100b) 0.097 ± 0.005 0.732 ± 0.011 0.356 ± 0.253
Lactation 10 8 (80b) 0.038 ± 0.006 0.843 ± 0.057 0.308 ± 0.315
Fatting Growing (earlyc) 10 9 (90b) 0.037 ± 0.024 0.982 ± 0.329 0.321 ± 5.032
Growing (lated) 5 5 (100b) 0.043 ± 0.008 0.492 ± 0.014 0.151 ± 0.193
Total 50 44 (88 b)
Poultry feeds
Layer Chicken 15 15 (100b) 0.045 ± 0.001 1.097 ± 0.201 0.282 ± 0.297
Laying 11 10 (91b) 0.035 ± 0.008 1.492 ± 0.448 0.255 ± 0.452
Broiler Broiler (earlyc) 10 8 (80b) 0.042 ± 0.021 0.139 ± 0.023 0.089 ± 0.038
Broiler (lated) 9 7 (78b) 0.051 ± 0.026 0.333 ± 0.009 0.145 ± 0.096
Parent stock Breeder 5 3 (60b) 0.079 ± 0.013 0.749 ± 0.181 0.329 ± 0.336
Total 50 43 (86b)
Feed ingredients
Vegetable proteins Soybean meal 2 0 (0) - -
Corn gluten 4 1 (25b) 0.050 ± 0.015 0.050 ± 0.015 0.050 ± 0.015
Corn germ meal 2 2 (100b) 0.083 ± 0.005 0.094 ± 0.004 0.089 ± 0.007
Otherse 10 6 (60b) 0.555 ± 0.031 0.957 ± 0.003 0.663 ± 0.150
Bran Wheat bran 1 0 (0) - - -
Othersf 8 7 (87.5b) 0.075 ± 0.012 0.640 ± 0.099 0.421 ± 0.232
Others By-products of food 2 0 (0b) - - -
Grain products 1 0 (0) - - -
Total 30 16 (53.33b)
Total 180 153 (85 b)
Open in a new tab

Notes: a: Samples with DON concentrations ≥LOQ (0.035 mg/kg) were used in the analyses; b: Concentration (%); c: Early: under three months; d: Late: 3 to 6 months; e: Others: distillers dried grains, palm oil meal, coffee meal; f: Others: corn gluten feed, wheat bran, cotton seeds hull, corn-bran, wheat shorts, wheat flour.

Table 1 also explained DON contamination and 53.33% of the feed ingredient samples were contaminated with DON, with a mean concentration of 0.447 mg/kg, ranging from 0.050 to 0.957 mg/kg. These levels were lower than those listed by the commission regulation of the European Community. The highest level of DON was observed in a vegetable protein samples (0.957 mg/kg) among all the feed ingredients tested. The contamination range of DON in feed ingredient samples was consistent with the observations of Binder et al. (2007), who analyzed feeds and feed ingredients for the presence of DON in North Asia [11]. Unlike aflatoxin B1, DON was highly prevalent in that region (71%), and the highest level (18.991 mg/kg) was detected in a wheat sample sourced in China. In their study, the mean level of DON was 0.162 mg/kg and the level was lower than our study.

Consistent with the results in the present study, Monbaliu et al. (2010) reported that DON was detected in 52 samples with mean level of 0.949 mg/kg and 12 samples were contaminated with ZEN as mean level of 0.157 mg/kg. The samples were collected from three EU countries; Czech Republic, Denmark, and Hungary. This report also presented the contamination of FB1 and FB2 in 36 and 29 samples with mean levels of 0.913 and 0.292 mg/kg, respectively [12]. Several research articles reported that the levels of mycotoxins in compound feeds were lower than those observations in feed ingredients [13,14] mainly due to the dilution of mycotoxins by cleaning and mixing steps during processing. However, in our previous reports related to contamination of Fusarium mycotoxin (FB1, FB2, and beauvericin) in animal feeds in Korea, we also found higher contamination levels in compound feeds than those levels in feed ingredient [15,16] as shown in the present study. This tendency can be explained by following two points of view. First, the contamination levels of Fusarium mycotoxins in animal feeds and feed ingredients in Korea are relatively lower than those observations in other countries or much the same [4,10,11,18]. Therefore, the tendency that the levels of contamination observed in compound feeds are higher than those reported for feed ingredient can be observed mainly due to the relatively lower contamination levels of Fusarium mycotoxins in feed ingredients. Second, several compound feeds in Korea contain corn-gluten feed (between 10% and 20%) as a feed ingredient which showed the highest levels of Fusarium mycotoxin, as shown in “others” presented in Table 1, Table 2 and Table 3. The addition of this feed ingredient could be the main reason why the levels of contamination observed in compound feeds are high compared with those levels in feed ingredients. Further study should be performed to explain this observation by investigation of storage conditions, processing steps and distribution of compound feeds in Korea.

Table 2.

The presence of fumonisins B1 and B2 (FBs) in compound feeds and feed ingredient samples.

Samples Number (%) of FBs contaminated samples Concentration (mg/kg)
Type Total number Contaminated number Minimum ± SD Maximum ± SD Mean ± SD
Cattle feeds
Breeding Pregnancy 5 4 (80b) 0.102 ± 0.033 1.125 ± 0.000 0.492 ± 0.449
Lactation Lactation 11 11 (100b) 0.042 ± 0.003 2.560 ± 2.508 1.038 ± 1.000
Calf 11 11 (100b) 0.045 ± 0.005 2.990 ± 0.000 0.691 ± 0.851
Fatting Calves 11 11 (100b) 0.099 ± 0.003 2.007 ± 0.154 0.803 ± 0.637
Finishing (earlyc) 6 6 (100b) 0.556 ± 0.049 1.472 ± 0.117 1.130 ± 0.355
Finishing (lated) 6 6 (100b) 0.082 ± 0.000 2.020 ± 0.102 0.584 ± 0.757
Total 50 49 (98b)
Swine feeds
Piglets 5 5 (100b) 0.038 ± 0.005 0.420 ± 0.028 0.255 ± 0.139
Piglets ≥ 5 kg 10 7 (70b) 0.037 ± 0.000 1.160 ± 0.002 0.387 ± 0.388
Breeding Pregnancy 10 8 (80b) 0.120 ± 0.000 5.509 ± 0.008 1.108 ± 1.847
Lactation 10 9 (90b) 0.065 ± 0.000 0.680 ± 0.122 0.290 ± 0.332
Fatting Growing (earlyc) 10 7 (70b) 0.114 ± 0.025 1.280 ± 0.113 0.359 ± 0.421
Growing (lated) 5 5 (100b) 0.097 ± 0.009 0.257 ± 0.082 0.183 ± 0.064
Total 50 41 (82b)
Poultry feeds
Layer Chicken 15 15 (100b) 0.145 ± 0.008 9.383 ± 0.013 1.577 ± 2.384
Laying 11 11 (100b) 0.315 ± 0.058 4.530 ± 0.093 2.314 ± 1.818
Broiler Broiler (earlyc) 10 10 (100b) 0.333 ± 0.006 12.823 ± 4.442 3.459 ± 3.840
Broiler (lated) 9 9 (100b) 0.092 ± 0.035 4.757 ± 5.247 1.614 ± 1.488
Parent stock Breeder 5 5 (100b) 0.299 ± 0.000 4.382 ± 0.024 2.166 ± 1.502
Total 50 50 (100b)
Feed ingredients
Vegetable proteins Soybean meal 2 2 (100b) 0.059 ± 0.003 0.150 ± 0.008 0.105 ± 0.064
Corn gluten 3 3 (100b) 0.805 ± 0.029 2.694 ± 0.079 1.477 ± 1.056
Corn germ meal 2 2 (100b) 0.283 ± 0.004 0.534 ± 0.005 0.409 ± 0.177
Otherse 11 7 (54.55b) 0.216 ± 0.001 2.748 ± 0.030 1.539 ± 1.137
Bran Wheat bran 1 1 (100b) 0.069 ± 0.000 0.069 ± 0.000 0.069 ± 0.000
Othersf 7 7 (100b) 0.565 ± 0.041 8.239 ± 0.116 3.378 ± 3.241
Others By-products of food 3 3 (100b) 0.066 ± 0.000 0.164 ± 0.006 0.106 ± 0.052
Grain products 1 0 (0) - - -
Total 30 25 (83.33b)
Total 180 165 (91.67b)
Open in a new tab

Notes: a: Samples with FB1 concentrations ≥LOQ (0.030 mg/kg) and FB2 concentrations ≥LOQ (0.035 mg/kg) were used for analysis; b: Concentration(%); c: Early: under 3 months; d: Late: 3 to 6 months; e: Others: distillers dried grains, palm oil meal, coffee meal; f: Others: corn gluten feed, wheat bran, cotton seeds hull, corn-bran, wheat shorts, wheat flour.

Table 3.

The presence of zearalenone (ZEN) in compound feeds and feed ingredient samples.

Samples Number (%) of ZEN contaminated samples Concentration (mg/kg)
Type Total number Contaminated number Minimum ± SD Maximum ± SD Mean ± SD
Cattle feeds
Breeding Pregnancy 5 5 (100b) 0.011 ± 0.001 0.100 ± 0.050 0.057 ± 0.038
Lactation Lactation 11 11 (100b) 0.010 ± 0.004 0.262 ± 0.117 0.095 ± 0.101
Calf 11 10 (91b) 0.009 ± 0.000 0.265 ± 0.008 0.094 ± 0.024
Fatting Calves 11 11 (100b) 0.029 ± 0.016 0.405 ± 0.087 0.194 ± 0.134
Finishing
(earlyc)		 6 6 (100b) 0.024 ± 0.008 0.153 ± 0.038 0.073 ± 0.058
Finishing
(lated)		 6 6 (100b) 0.015 ± 0.004 0.186 ± 0.005 0.114 ± 0.069
Total 50 49 (98b)
Swine feeds
Piglets 5 1 (20b) 0.200 ± 0.257 0.200 ± 0.257 0.200 ± 0.257
Piglets ≥ 5 kg 10 6 (60b) 0.008 ± 0.001 0.046 ± 0.003 0.029 ± 0.019
Breeding Pregnancy 10 6 (60b) 0.017 ± 0.004 0.086 ± 0.013 0.032 ± 0.017
Lactation 10 6 (60b) 0.008 ± 0.004 0.207 ± 0.048 0.046 ± 0.019
Fatting Growing
(earlyc)		 10 7 (70b) 0.008 ± 0.005 0.055 ± 0.047 0.026 ± 0.020
Growing
(lated)		 5 4 (80b) 0.009 ± 0.002 0.019 ± 0.027 0.013 ± 0.002
Total 50 30 (60b)
Poultry feeds
Layer Chicken 15 10 (67b) 0.010 ± 0.000 0.132 ± 0.006 0.044 ± 0.012
Laying 11 3 (27b) 0.013 ± 0.011 0.228 ± 0.008 0.109 ± 0.012
Broiler Broiler
(earlyc)		 10 5 (50b) 0.008 ± 0.001 0.020±0.006 0.012 ± 0.006
Broiler
(lated)		 9 8 (89b) 0.009 ± 0.002 0.038 ± 0.003 0.027 ± 0.009
Parent stock Breeder 5 2 (40b) 0.012 ± 0.002 0.087 ± 0.020 0.050 ± 0.011
Total 50 28 (56b)
Feed ingredients
Vegetable proteins Soybean meal 2 0 (0b) - - -
Corn gluten 4 1 (25b) 0.148 ± 0.001 0.148±0.001 0.148 ± 0.001
Corn germ meal 2 2 (100b) 0.014 ± 0.002 0.413 ± 0.004 0.327 ± 0.087
Otherse 10 5 (50b) 0.013 ± 0.003 0.077 ± 0.096 0.029 ± 0.023
Bran Wheat bran 1 0 (0) - - -
Othersf 8 6 (75b) 0.010 ± 0.004 0.291 ± 0.004 0.129 ± 0.028
Others By-products of food 1 0 (0)
Grain products 2 0 (0) - - -
Total 30 14 (47b)
Total 180 121 (67.22b)
Open in a new tab

Notes: a: Samples with ZEN concentrations ≥LOQ (0.008 mg/kg) were used for analysis; b: Concentration (%); c: Early: under three months; d: Late: 3 to 6 months; e: Others: distillers dried grains, palm oil meal, coffee meal; f: Others: corn gluten feed, wheat bran, cotton seeds hull, corn-bran, wheat shorts, wheat flour.

Contamination Levels of FBs in Compound Feeds and Feed Ingredients

As shown in Table 2, FBs were detected in 98% of cattle feeds, at concentrations ranging from 0.042 to 2.990 mg/kg. The lactation calf feed exhibited the highest contamination of FBS, with a mean contamination level of 0.691 mg/kg. Eighty-two percent of the 50 tested samples of swine feed were contaminated with FBs, with levels ranging from 0.037 to 5.509 mg/kg. The breeding pregnancy feed was contaminated with the highest levels of FBs, and the mean level of contamination was 1.108 mg/kg. These FBs levels were lower than the levels previously reported by our research group in animal feeds distributed in South Korea in 2011 [16] and they were all lower than those mentioned in the commission regulation of the European Community. However, Martins et al. (2011) reported that 8.7% of swine feed samples in Portugal were contaminated with FBs in 2010, which is significantly lower than the percentage observed in this study [17]. All of the poultry feed samples were contaminated with FBs, and the contamination levels ranged from 0.092 to 12.823 mg/kg, with a mean of 2.181 mg/kg. Broiler (early) feeds contained the highest contamination with FBs, with mean levels of 3.459 mg/kg. A similar contamination level of FBs was reported by Klarić et al. (2009) in Croatia with a mean level of 3.690 mg/kg in cereals and contaminated feed collected in 2007 from households of an endemic nephropathy area [18].

Several research articles reported contamination of FBs in forms of FB1 and FB2, separately. In a study of simultaneous occurrence of FB1 in China, Chu and Li (1994) reported that the corn collected from two regions was heavily contaminated with FB1 at a mean level of 94 mg/kg [4]. In the investigation of Portuguese corn-based products, Waskiewicz et al. (2012) reported that FB1 was detected in all corn flour samples analyzed, and FB2 was detected in 70.7% of tested samples. The concentrations of FB1 and FB2 ranged from 0.050 to 1.300 mg/kg, and 0.100–0.450 mg/kg, respectively [19]. Consistent with other studies, the contamination levels of FB2 were lower than those of FB1 in all tested animal feeds and feed ingredients and all FB2 contaminated samples were co-contaminated with FB1 [20,21].

Table 2 also presented contamination of FBs in 25 feed ingredient samples (83.33%), with lower contamination levels ranging from 0.059 to 8.239 mg/kg, and a mean contamination level of 1.611 mg/kg compare with those observations in compound feeds. These levels were lower than the levels of FBs described by the commission regulation of the European Community. The data in these results were consistent with those reported by Binder et al. (2007), who assessed the presence of FBs (FB1, FB2, and FB3) in feed ingredients in Asia and Oceania [11]. The highest level of contamination with FBs was found in a feed ingredient from China, with concentrations of 14.714 mg/kg. The total contamination incidence in China was 16% in feed ingredients that were collected from the same regions.

Contamination Levels of ZEN in Compound Feeds and Feed Ingredients

ZEN was detected in 98% of the cattle feeds, with concentrations ranging from 0.009 to 0.405 mg/kg (Table 3). The fatting calves feed exhibited the highest contamination of ZEN, with a mean contamination of 0.194 mg/kg. In the study of cattle feeds in Turkey, Kocasari et al. (2013) reported that ZEN was detected in 45.2% of tested samples at concentrations ranging from 0.002 to 0.029 mg/kg [21]. Sixty percent of the 50 swine feed samples were contaminated with ZEN, at concentrations ranging from 0.008 to 0.207 mg/kg at a mean of 0.036 mg/kg. Out of the swine feed samples, breeding lactation feed was contaminated with the highest levels of ZEN. A total of 56% of the poultry feed samples were contaminated with ZEN, and the contamination levels ranged from 0.008 to 0.228 mg/kg, with a mean of 0.041 mg/kg. This level is lower than that listed in the commission regulation of the European Community. Consistent with our observations, Labuda et al. (2005) reported that 88% of poultry feed samples were contaminated with ZEN, and that levels ranged from 0.003 to 0.086 mg/kg (mean 0.021 mg/kg) in Slovakia in 2004 [10].

Forty-seven percent of feed ingredients were contaminated with ZEN (14 feed ingredient samples out of 30 samples) at the concentrations range of 0.010–0.413 mg/kg. The mean contamination level was 0.123 mg/kg, which is lower than the levels of ZEN specified in the commission regulation of the European Community. Interestingly, all tested corn gluten and corn germ meal samples were contaminated with ZEN. Several researchers in different countries have reported the presence of ZEN in feed ingredients. Binder et al. (2007) analyzed the presence of ZEN in feed ingredients in Asia and Oceania [11], and reported mean ZEN contamination levels of 0.077 mg/kg in feed ingredients, which is comparable to our observations. The total incidence of contamination was 24% in feed ingredients that were collected from the same regions, which is much lower than those observed in this study.

Co-contamination of the Three Toxins in Compound Feeds and Feed Ingredients

Co-contamination of Fusarium mycotoxins is of great of interest as mycotoxigenic fungi are capable of producing more than one mycotoxin and feed raw materials might be infected with various fungal species. Thus, studying the occurrence of any given mycotoxin alone does not provide sufficient information about the risk associated with the respective feedstuffs [22]. Simultaneous occurrence of mycotoxins appears to exert greater negative effects on health and productivity than single mycotoxins [23], if there is no appropriate investigation, and management of mycotoxins in feeds and all relevant precautions have to be considered.

As illustrated in Table 4, most of the samples showed co-occurrence of mycotoxins at the same time. Cattle feeds showed the highest percentage of co-occurrence of mycotoxins followed by poultry feeds, swine feeds and ingredient samples. Some samples heavily contaminated with FBs or DON and usually contaminated with ZEN weakly. For example, one broiler (early) feed for poultry exhibited the maximum contamination level of FBs (12.823 mg/kg) were co-contaminated with the lower levels of DON (0.139 mg/kg) and ZEN (0.020 mg/kg). Other poultry feed for layer (laying) with the highest contamination level of DON (1.492 mg/kg) was also co-contaminated with FBs (4.530 mg/kg) and ZEN (0.228 mg/kg), respectively.

Table 4.

Co-contamination of three toxins in animal feeds.

Categories DON + FBs + ZEN The range of DON
(mg/kg)		 The range of FBs
(mg/kg)		 The range of ZEN
(mg/kg)
Cattle feeds 48/50 0.131–1.000 0.042–2.990 0.009–0.405
Swine feeds 25/50 0.037–0.982 0.037–5.509 0.008–0.207
Poultry feeds 27/50 0.035–1.492 0.092–12.823 0.008–0.228
Feed ingredient 12/30 0.050–0.957 0.059–8.239 0.010–0.413
Total 112/180
Open in a new tab

3. Materials and Methods

3.1. Samples

Compound feed and feed ingredient samples were collected from various regions in South Korea, and provided by the National Agriculture Products Quality Management Service Experiment Research Institute in 2012. The samples were prepared following the sampling guide in the code for the control of feeds (FAO/WHO 2004). One kilogram of sample was taken randomly from every ton of feed ingredients or compound feeds. Four different samples were pooled and divided into four groups, according to the sampling guide in the code for the control of feeds. Five hundred grams of the divided samples were tested for contamination with DON, FB1, FB2, and ZEN. The concentrations of DON, FB1, FB2, and ZEN were assessed in 150 samples of compound feeds, including cattle feed, swine feed, and poultry feed, and 30 samples of feed ingredients including vegetable proteins, and bran. The samples were stored at 4 °C before analysis to maintain the condition of the samples.

3.2. Extraction and Purification of DON, FBS, and ZEN

Feed samples were milled to obtain a particle size of 600 μM. DON was analyzed and validated as described in the Korean Food Standards Codex method (2010) for the determination of DON in corn and corn flakes. Twenty grams of each feed sample was extracted in 100 mL distilled water by homogenizing (OMNI MACRO ES HOMOGENIZER, USA) for 2 min at 10,000 rpm. The extract was then filtered through Whatman No. 6 filter paper, and 2.5 mL of filtered extract was applied to the immunoaffinity column (IAC; Vicam, DON test) containing specific antibodies for DON for purification. The IAC was washed with 5 mL 100% water, and DON was slowly eluted in 3 mL 100% methanol at 1 drop/s. The elute was collected and evaporated to dryness under nitrogen steam (50 °C).

The analysis and validation of FB1 and FB2 were carried out in all samples according to the AOAC official method for the determination of fumonisins B1 and B2 (AOAC 2001). Twenty grams of feed sample was extracted with 100 mL of extraction solvent (25:25:50 methanol:acetonitrile:water, v/v/v) using a homogenizer for 2 min at 10,000 rpm. The extract was then filtered through Whatman No. 6 filter paper. Ten milliliters of the filtered extract was diluted in 40 mL phosphate-buffered saline (PBS; Sigma-Aldrich, St. Louis, MO, USA), and the diluted extracts were collected and purified through an IAC-containing fumonisin-specific antibodies. The IAC was rinsed with 10 mL PBS, and FB1 and FB2 were then eluted from the column using 4 mL 80% methanol at 1 drop/s. The eluted fraction was evaporated to dryness under nitrogen steam at 60 °C, and stored at 4 °C for derivatization before being analyzed by high-performance liquid chromatography (HPLC).

The ZEN assay and validation were performed as the Korean Food Standards Codex method (2010) for quantifying ZEN in corn and corn flakes. Twenty-five grams of each feed sample was extracted with 100 mL 75% acetonitrile containing 1 mL Tween20 and 2 g NaCl at 10,000 rpm for 5 min. The extract was filtered through Whatman No.4 filter paper, and 10 mL filtered extract was diluted with 40 mL distilled water. Twenty-five milliliters of diluted extract was then purified using an IAC. The IAC was washed with 20 mL water at a flow-rate of 1 drop per second, and the elute was collected in 5 mL methanol and evaporated using nitrogen steam (40 °C).

3.3. HPLC Analysis

For DON, the dried samples were re-dissolved in 0.5 mL of acetonitrile:water (17:83, v/v). The samples (20 μL) were analyzed using HPLC (Agilent Technology 1260 series; Agilent, Santa Rosa, CA, USA) equipped with an Agilent Technology 1200 Infinity UV Detector. An analytical column (ZORBAX Eclipse XDB-C18 column, 4.6 × 250 mm, 5 μM, Agilent, USA) was used for HPLC analysis for 20 min at a constant flow rate of 1 mL/min at 30 °C, and DON was detected at an absorbance of 220 nm.

To analyze FB1 and FB2, the dried samples from IAC were re-dissolved in 0.5 mL acetonitrile:water (50:50, v/v). Because this sample did not exhibit any fluorescence, it was derivatized using o-phthalaldehyde (OPA) reagent. Twelve microliters OPA was mixed with 10 μL sample using an auto-program in the HPLC (Agilent Technology 1200 series; Agilent, USA) equipped with Agilent Technology 1260 Infinity Fluorescence Detector. The isocratic mobile phase (77:23 MeOH:0.1 M NaH2PO4, adjusted to pH 3.3 with H3PO4) and analytical column (ZORBAX Eclipse XDB-C18 column, 4.6 × 250 mm, 5 μM, Agilent, USA) were used for HPLC analysis for 30 min at a constant flow rate of 1 mL/min at 30 °C. FB1 and FB2 were detected by fluorescence with an excitation at 335 nm and emission at 440 nm.

For ZEN, HPLC analysis was performed on an Agilent Technology 1200 series machine (Agilent, USA) for 20 min at a flow-rate of 1 mL/min. The mobile phase consisted of a mixture of methanol-water-acetonitrile (55:35:10, v/v/v), and an analytical column (ZORBAX Eclipse XDB-C18 column, 4.6 × 250 mm, 5 mm, Agilent, USA) was used for HPLC analysis. Twenty milliliters reconstituted extract was injected into the HPLC, and ZEN was measured (Agilent Technology 1260 Infinity Fluorescence Detector; Agilent, USA) with an excitation at 275 nm and emission at 450 nm.

The analysis was done in duplication and the data was presented with ± SD which indicated mean ± SD of replication done on different samples of the same feed.

3.4. Limit of Detection (LOD) and Limit of Quantification (LOQ)

DON standard powder was purchased from Sigma-Aldrich (St. Louis, Mo, USA), and a standard solution of DON (1 mg/mL) in 17% acetonitrile was stored in a sealed vial at −20 °C until use. A standard solution of mixed FB1 and FB2 containing 50 μg/mL each mycotoxin was purchased from Sigma-Aldrich, and diluted in 50% acetonitrile to create 0.5 μg/mL standard solution, which was stored until needed to make a standard curve. ZEN standard powder was also purchased from Sigma Aldrich and, 1 mg powder was dissolved in 100% acetonitrile as the stock solution, which was then further diluted in 100% acetonitrile to make the standard curve. The LOD was calculated at three times the signal-to-noise ratio, and LOQ was calculated at 10 times the signal-to-noise ratio.

The limit of detection (LOD) of DON was 0.010 mg/kg, and the limit of quantification (LOQ) was 0.035 mg/kg. Consistent with this, Bensassia et al. (2010) reported an LOD of 0.010 mg/kg and an LOQ of 0.030 mg/kg [24].

For FB1 and FB2, the LODs were 0.020 and 0.025 mg/kg, respectively, and the LOQs were 0.030 mg/kg for FB1 and 0.035 mg/kg for FB2. In a previous study, Krska et al. (2007) reported that the LOD of FBs in feeds ranged from 0.010 to 0.050 mg/kg sample dry weights, which is consistent with our observations [25]. However, they reported LOQs of FBs in feeds in the range of 0.070–0.090 mg/kg [10], which is significantly higher than those reported from the present study.

For ZEN, the LOD and LOQ were 0.003 mg/kg and 0.008 mg/kg, respectively. Previously, Eskola et al. (2002) reported an LOD of ZEN of 0.002 mg/kg, and an LOQ of 0.003 mg/kg [26], which is lower than the LOD detected in our study.

3.5. LC-MS/MS Analysis

Liquid chromatography-tandem mass spectrometry (LC-MS/MS; Agilent HPLC, ABI 4000, USA) was used to confirm the type of DON and ZEN in the negative electrospray ionization (ESI−) mode, and FB1 and FB2 in the positive mode (ESI+). An analytical column (Imtakt Scherzo SM-C18) was used (2.0 × 150 mm, 3 μM) under gradient conditions with a flow rate of 0.25 mL/min with the mobile phase consisting of 20% acetonitrile containing 2 mM ammonium acetate, and acetonitrile containing 0.3% formic acid. Ten microliters sample was injected in to the HPLC and LC-MS/MS system, and the molecular weights of analyzed mycotoxins were compared with of the standard solutions. The source voltage was set in as 4.5 kV at positive mode and −4.5 kV at negative mode with ion source temperature at 450 °C. In the negative mode, the precursor ion [M + CH3COOH]− of DON exhibited an m/z value of 355.1, with daughter product ions at 295.2 and 58.9 in MS/MS analysis. In the positive mode, the precursor ion [M + H]+ of FB1 showed m/z of 722.4, which resulted in daughter product ions of 336.3 and 334.3 in MS/MS analysis. The EIC and MRM of FB2, in which the peak of precursor ion [M + H]+ was found at an m/z value of 706.4, with daughter product ions at 336.3 and 273.1 in the same mode of MS/MS analysis. ZEN in samples was detected as a peak of m/z 317, which was consistent with the M/Z value of the ZEN standard. The M/Z values of the daughter product ions were 131.0 and 175.0.

4. Conclusions

Among the tested compound feeds and feed ingredients, 91.67% of the animal feeds were contaminated with FBs. In addition, 85% were contaminated with DON, and 67.22% were contaminated with ZEN. The contamination levels of DON, FBs, and ZEN were 0.035–1.492, 0.037–12.823, and 0.008–0.413 mg/kg, respectively. This study revealed that the contamination levels of Fusarium mycotoxins (DON, FBs, and ZEN) were lower than the maximum levels set by the commission regulation of the European Community (EU 2006) except one sample for swine feed (FBs, 5.5 mg/kg). However, the percentage of mycotoxin samples was noticeably high (67%–92%), suggesting that most animal feeds distributed in South Korea are contaminated. In addition, co-contamination of Fusarium mycotoxins in most samples makes it more concerning for animal health and reproduction and all relevant precautions have to be considered. Moreover, guidelines or maximum levels should not only be set for each mycotoxin individually but also for particularly concerning combinations of these toxins as it would be a more effective way to monitor feed safety in relation to mycotoxin contamination, and continuous monitoring of mycotoxins in feeds is therefore necessary for improving feed safety.

Acknowledgments

This work was supported by the Basic Science Research Program through the National Research Foundation of Korea (NRF) funded by the Ministry of Education, Science and Technology (2012R1A2A2A01003635) and by the Chung-Ang University Excellence Student Scholarship.

Conflicts of Interest

The authors declare no conflict of interest.

References

  • 1.Shier W.T., Badria F., Crepp E.E. Cytotoxicity of fumonisin B1: Implication of lipid peroxidation and inhibition of protein and DNA syntheses. Arch. Toxicol. 1998;72:233–236. doi: 10.1007/s002040050494. [DOI] [PubMed] [Google Scholar]
  • 2.D’Mello J.P.F., Macdonald A.M.C., Postel D., Hunter E.A. 3-acetyl deoxynivalenol production in a strain of Fusarium culmorum insensitive to the fungicide difenoconazole. Mycotox. Res. 1997;13:73–79. doi: 10.1007/BF02945069. [DOI] [PubMed] [Google Scholar]
  • 3.Miller D., Taylor A., Greenhalgh R. Production of deoxynivalenol and related compounds in liquid culture by Fusarium graminearum. Can. J. Microbiol. 1983;29:1171–1178. doi: 10.1139/m83-179. [DOI] [Google Scholar]
  • 4.Greenhalgh R., Levandier D. Production and characterization of deoxynivalenol and other secondary metabolites of Fusarium culmorum. J. Agric. Food Chem. 1986;34:98–102. doi: 10.1021/jf00067a027. [DOI] [Google Scholar]
  • 5.Jelinek C.F., Pohland A.E., Wood G.E. Worldwide occurrence of mycotoxins in foods and feeds-an update. J. Assoc. Off. Anal. Chem. 1989;72:223–230. [PubMed] [Google Scholar]
  • 6.Forsyth D.M., Yoshizawa T., Morooka N., Tuite J. Emetic and refusal activity of deoxynivalenol to swine. Appl. Environ. Microb. 1977;34:547–552. doi: 10.1128/aem.34.5.547-552.1977. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 7.Creppy E.E. Update of survey, regulation and toxic effects of mycotoxins in Europe. Toxicol. Lett. 2002;127:19–28. doi: 10.1016/s0378-4274(01)00479-9. [DOI] [PubMed] [Google Scholar]
  • 8.Fun S.C., Guo Y.L. Simultaneous occurrence of fumonisin B1 and other mycotoxins in moldy corn collected from the People’s Republic of China in regions with high incidences of esophageal cancer. Appl. Environ. Microb. 1994;60:847–852. doi: 10.1128/aem.60.3.847-852.1994. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 9.Placinta C.M., D’Mello J.P.F., Macdonald A.M.C. A review of worldwide contamination of cereal grains and animal feed with Fusarium mycotoxins. Anim. Feed Sci. Technol. 1999;78:21–37. [Google Scholar]
  • 10.Labuda R., Parich A., Berthiller F. Incidence of trichothecenes and zearalenone in poultry feed mixtures from Slovakia. Int. J. Food Microbiol. 2005;105:19–25. doi: 10.1016/j.ijfoodmicro.2005.06.005. [DOI] [PubMed] [Google Scholar]
  • 11.Binder E.M., Tan L.M., Chin L.J., Hnadl J., Richard J. Worldwide occurrence of mycotoxins in commodities, feed and feed ingredients. Anim. Feed Sci. Technol. 2007;132:265–282. [Google Scholar]
  • 12.Monbaliu S., Poucke C.V., Detavernier C., Dumoulin F., Velde M.V., Schoeters E., Dyck S.V., Averkieva O., Peteghem C.V., Saeger S.D. Occurrence of mycotoxins in feed as analyzed by a multimycotoxin LC-MS/MS method. J. Agric. Food Chem. 2010;58:66–71. doi: 10.1021/jf903859z. [DOI] [PubMed] [Google Scholar]
  • 13.Jindal N., Mahipal S.K., Rottinghaus G.E. Occrrence of fumonisin B1 in maize and poultry feeds in Haryana, India. Mycopathologia. 1999;148:37–40. doi: 10.1023/A:1007162113368. [DOI] [PubMed] [Google Scholar]
  • 14.Prathapkumar H.S., Ramesh V.B. Natural occurrence of fumonisin B1 and its co-occurrence with aflatoxin B1 in Indian sorghum, maize and poultry feeds. J. Agric. Food Chem. 1997;45:2170–2173. doi: 10.1021/jf960607s. [DOI] [Google Scholar]
  • 15.Kyungeun L., Byunghee K., Chan L. Occurrence of Fusarium mycotoxin beauvericin in animal feeds in Korea. Anim. Feed Sci. Technol. 2010;157:190–194. doi: 10.1016/j.anifeedsci.2010.03.003. [DOI] [Google Scholar]
  • 16.Donggeun S., Chanvorleak P., Chan L. Occurrence of Fusarium mycotoxin fumonisin B1 and B2 in animal feeds in Korea. Mycotox. Res. 2013;29:159–167. doi: 10.1007/s12550-013-0172-0. [DOI] [PubMed] [Google Scholar]
  • 17.Almeida I., Martins H.M. Co-occurrence of mycotoxins in swine feed produced in Portugal. Mycotox. Res. 2011;27:177–181. doi: 10.1007/s12550-011-0093-8. [DOI] [PubMed] [Google Scholar]
  • 18.Klarić M.S., Cvetnić Z., Pepelnjnak S., Kosalec I. Co-occurrence of aflatoxins, ochratoxin A, fumonisins, and zearalenone in cereals and feed, determined by competitive direct enzyme-linked immunosorbent assay and thin-layer chromatography. Arh. Hig. Rada. Toksikol. 2009;60:427–434. doi: 10.2478/10004-1254-60-2009-1975. [DOI] [PubMed] [Google Scholar]
  • 19.Waskiewicz A., Beszterda M., Golinski P. Occurrence of fumonisisns in food-an interdisciplinary approach to the problem. Food Control. 2012;26:491–499. doi: 10.1016/j.foodcont.2012.02.007. [DOI] [Google Scholar]
  • 20.Chehri K., Jahromi S.T., Reddy K.R.N. Occurrence of Fusarium spp. and fumonisins in stored wheat grains marketed in Iran. Toxins. 2010;2:2816–2823. doi: 10.3390/toxins2122816. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 21.Kocasari F.S., Mor F., Oguz M.N. Occurrence of mycotoxins in feed samples in Burdur Province. Turkey Environ. Monit. Assess. 2013;185:4943–4949. doi: 10.1007/s10661-012-2915-3. [DOI] [PubMed] [Google Scholar]
  • 22.Elisabeth S., Gerd S., Panagiotis T., Eleni T., Daniela M., Ionelia T., Cristina T., Anca N., Iuliana A., Olivier P., et al. Current situation of mycotoxin contamination and co-occurrence in animal feed-focus on Europe. Toxins. 2012;4:788–809. doi: 10.3390/toxins4100788. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 23.Audrone M., Bronislava B., Zenonas D. Peculiarities of cereal grain co-contamination with Fusarium mycotoxins. Zemdirbyste. 2011;4:415–420. [Google Scholar]
  • 24.Bensassia F., Zaieda C., Abida S. Occurrence of deoxynivalenol in durum wheat in Tunisia. Food Control. 2010;21:281–285. doi: 10.1016/j.foodcont.2009.06.005. [DOI] [Google Scholar]
  • 25.Krska R., Welziga E., Boudra H. Analysis of Fusarium toxins in feed. Anim. Feed Sci. Technol. 2007;137:241–264. doi: 10.1016/j.anifeedsci.2007.06.004. [DOI] [Google Scholar]
  • 26.Eskola M., Kokkonen M. Application of manual and automated systems for purification of ochratoxin A and zearalenone in cereals with immunoaffinity columns. J. Agric. Food Chem. 2002;50:41–47. doi: 10.1021/jf010743j. [DOI] [PubMed] [Google Scholar]

Articles from Toxins are provided here courtesy of Multidisciplinary Digital Publishing Institute (MDPI)

RESOURCES