Occupational Exposure Limits (OELs) for Chemical Substances
Ethylidene norbornene [CAS No. 16219-75-3] is a white to colorless liquid (boiling point 148°C, vapor pressure 560 Pa (20°C) ) with a characteristic odor used for the production of automobile synthetic rubber products, ethylene propylene diene methylene linkage. The OEL-Mean of 2 ppm (10 mg/m3) is proposed based on the results of animal experiments1). In the 14-week inhalation exposure experiment (5 to 150 ppm) with Fischer 344 rats, swelling and crust formation around the eyes were observed in the female group of 5 ppm or more, and the effects on the thyroid gland (e.g., follicular colloid reduction, hypertrophy, and hyperplasia of follicular epithelial cells, etc.) was observed in the group of 25 ppm or more in males and females. Although the implantation rate and the fertility rate decreased in animals and the incidence of skeletal mutation of the three species of pediatric animals was increased, these effects were observed at concentrations where an increase in the relative weight of the liver to the mother was observed. Thus, we propose the Group 3 for reproductive toxicity2).
Ethyleneimine [CAS No. 151-56-4] is a colorless corrosive liquid with ammonia odor (boiling point 56°C) and vapor pressure of 160 torr (21.33 kPa) (20°C). It is used as production raw materials of pharmaceutical intermediate, polyethyleneimine, amino ethylation acrylic polymers, and the aziridine-based crosslinking agent. This chemical was recommended at 0.5 ppm (0.88 mg/m3) for OEL-M in 1966, added a skin absorption mark in 1990, categorized Group 2B for class of carcinogenicity in 2001, and was classified Group 3 as a reproductive toxicant in 2014. The Japan Society for Occupational Health (JSOH) reevaluated the OEL and other classifications by examining subsequent reports this time. The JSOH proposes 0.05 ppm (0.09 mg/m3) as OEL-M for ethyleneimine based on the results that observed effects such as bronchitis and liver and renal denaturation in a rat inhalation experiment3,4) of 10 mg/m3 (5.7ppm) for 4 hr/day and 1.5 months, and the reproductive toxicity such as decreases in the pregnancy rate exposed to 10 mg/m3 of ethyleneimine among pregnancy rats4). The skin absorbency, a carcinogenic classification (Group 2B), and a genotoxicity classification (Group 3) remains the same.
Benomyl [CAS No.17804-35-2] is a carbamate fungicide broadly used for rice, wheat, fruits, vegetables, and flowers, among others, and benomyl wettable powder and benomyl-tiuram wettable powder are registered pesticides in Japan. Benomyl is a white crystalline solid (melting point: 140°C with decomposition, vapor pressure: 5.0×10-6 Pa or lower [25°C]) and is unstable in water. After decomposition, benomyl is converted to carbendazim (metabolite). The OEL-M of 1 mg/m3 for benomyl is newly proposed based on the results of a 90-day nose-only inhalation toxicity study in Sprague-Dawley rats (10, 50 and 200 mg/m3)5), in which olfactory-epithelial degeneration was observed in the 50 mg/m3 and higher groups in male and in the 200 mg/m3 group in female. In addition, we propose the classification of benomyl into the second group of both skin sensitization and reproductive toxicity from the results of the animal experiments. Furthermore, since the exposure level below the OEL still requires caution according to an experimental result using pregnant female rats, we notify "#" indication for benomyl to call for attention6).
2,3-Epoxypropyl methacrylate (Glycidyl methacrylate, GMA) [CAS No. 106-91-2] is a colorless liquid with a characteristic odor (boiling point 189°C, vapor pressure of 0.42 kPa at 25°C) that reacts violently with strong acids, strong bases, and strong oxidants with the generation of fire hazard. It is used mainly as a raw material in the manufacture of acrylic resin, diluent of epoxide-based adhesive, stabilizing agent of polyvinyl chloride, ion-exchange resin, and binder of printing ink. The results of carcinogenicity and genotoxicity studies suggested a possible non-threshold carcinogen for rodents. However, because there is no available scientific knowledge of carcinogenicity in humans, assessing a dose-response relationship in human as a non-threshold carcinogen admits to large uncertainty. Therefore, the JSOH proposes 0.01 ppm (0.06 mg/m3) as the OEL-M for GMA, according to the dose-dependent pathological changes in olfactory and respiratory epithelia in the nasal cavity at concentrations of ≥0.6 ppm in the results of 2-year inhalation studies of B6D2F1/Crlj mice (0.6-10 ppm)7). In the assessment, an uncertainty factor for the severity of carcinogenic effect was taken into account. There was sufficient evidence in rats and mice of the carcinogenicity of GMA. The carcinogenicity classification is proposed as Group 2A. In the evaluation, it was taken into account that GMA is mutagenic in a wide range of in-vivo and in-vitro test systems. The OEL-M was set based on the non-carcinogenic effects. Thus, ψ notation is indicated for attention message. Skin absorption notation is indicated and skin occupational sensitizer classification is proposed as Group 2. The reproductive toxicant classification is proposed as Group 3.
Classifications on Carcinogenicity
Regarding the carcinogenicity classification, 2-nitrotoluene is proposed to be a Group 2A carcinogen. The proposed Group 2B carcinogens are vinylidene chloride, quinoline, diazinon, 2,4,6-Trichlorophenol, pyridine, 1-tert-Butoxypropan-2-ol, malathion and β-Myrcene.
The latest OEL recommendations (2018-2019) will appear in the September issue of the Journal of Occupational Health (Volume 60, Number 5). A brief summary of the proposal will be posted on the society's website (https://www.sanei.or.jp/oel-eng) in September.
Contributors: All the authors contributed to the draft preparation and deliberation of the proposals in the committee. The corresponding author (TT) developed and finalized the article based on the comments from all the other authors' feedback.
Conflicts of interest: The committee declares that have no conflicts of interest.
References
- 1). Ballantyne B, Norris JC, Dodd DE, et al. Short-term and subchronic repeated exposure studies with 5-ethylidene-2-norbornene vapor in the rat. Journal of Applied Toxicology 1997; 17 (4): 197-210. [DOI] [PubMed] [Google Scholar]
- 2). Neeper-Bradley TL, Ballantyne B. Absence of dominant lethal effects in male CD rats exposed to 5-ethylidene-2-norbornene vapor. Toxic Substance Mechanisms 1996; 15 (4): 389-404. [Google Scholar]
- 3). ACGIH. . Ethyleneimine. In: ACGIH Documentation of TLVs and BEIs. Ohio: ACGIH; 2009. [Google Scholar]
- 4). IARC. . Aziridine. IARC Monogr Eval Carcinog Risk Humans 1975; 9: 37-46. [PubMed] [Google Scholar]
- 5). Warheit DB, Kelly DP, Carakostas MC, et al. A 90-day inhalation toxicity study with benomyl in rats. Toxicological Sciences 1989; 12 (2): 333-345. [DOI] [PubMed] [Google Scholar]
- 6). Ellis WG, Semple JL, Hoogenboom ER, et al. Benomyl-induced craniocerebral anomalies in fetuses of adequately nourished and protein-deprived rats. Teratogenesis, carcinogenesis, and mutagenesis 1987; 7 (4): 357-375. [DOI] [PubMed] [Google Scholar]
- 7). Japan Bioassay Research Center (JBRC). . Report on carcinogenicity study of 2,3-epoxypropyl methacrylate in mice by two-year inhalation exposure: study no 0795; Hadano. Kanagawa: JBRC; 2015. (in Japanese). [Google Scholar]