Skip to main content
PMC home page
Scientific Reports logoLink to Scientific Reports
. 2020 Jul 6;10:11116. doi: 10.1038/s41598-020-68096-x

Critical thresholds of 1-Octen-3-ol shape inter-species Aspergillus interactions modulating the growth and secondary metabolism

Digar Singh 1, Su Young Son 1, Choong Hwan Lee 1,✉
PMCID: PMC7338521  PMID: 32632328

Abstract

In fungi, contactless interactions are mediated via the exchange of volatile organic compounds (VOCs). As these pair-wise interactions are fundamental to complex ecosystem, we examined the effects of inter-species VOCs trade-offs in Aspergillus flavus development. First, we exposed A. flavus to the A. oryzae volatilome (Treatment-1) with highest relative abundance of 1-Octen-3-ol (~ 4.53 folds) among the C-8 VOCs. Further, we examined the effects of gradient titers of 1-Octen-3-ol (Treatment-2: 100–400 ppm/day) in a range that elicits natural interactions. On 7-day, VOC-treated A. flavus displayed significantly reduced growth and sclerotial counts (p < 0.01) coupled with higher conidial density (T2100-200 ppm/day, p < 0.01) and α-amylase secretion (T2200 ppm/day, p < 0.01), compared to the untreated sets. Similar phenotypic trends except for α-amylases were evident for 9-day incubated A. flavus in T2. The corresponding metabolomics data displayed a clustered pattern of secondary metabolite profiles for VOC-treated A. flavus (PC1-18.03%; PC2-10.67%). Notably, a higher relative abundance of aflatoxin B1 with lower levels of most anthraquinones, indole-terpenoids, and oxylipins was evident in VOC-treated A. flavus. The observed correlations among the VOC-treatments, phenotypes, and altered metabolomes altogether suggest that the distant exposure to the gradient titers of 1-Octen-3-ol elicits an attenuated developmental response in A. flavus characterized by heightened virulence.

Subject terms: Biological techniques, Analytical biochemistry, Mass spectrometry, Metabolomics, Microbiology techniques, Microbiology, Environmental microbiology, Fungi

Introduction

Volatile organic compounds (VOCs) are characterized by low molecular weight (50–300 Da) and high vapor pressure (≥ 0.01 kPa at 20 °C) which make them highly diffusible through local atmosphere, shaping a multitude of ecological interactions across the prokaryotic and eukaryotic species1,2. VOCs of microbial origin are ubiquitous in nature and are perhaps the most elusive of the biogenic chemical entities. Fungi produce a variety of VOCs which mediate their spatiotemporal interactions in an ecosystem. Approximately three hundred VOCs belonging to different chemical classes have been characterized in fungi; these include alcohols, aldehydes, ketones, aromatics, esters, heterocyclic hydrocarbons, monoterpenes, sesquiterpenes, and furans3,4. A few studies have suggested the antagonistic roles of fungal VOCs, mediating their cross-kingdom ecological interactions, whereby the growth and metabolism of interacting species are significantly modulated. Particularly considering the role of volatile oxylipins in fungal interactions, C-8 (eight C-atoms) fungal VOCs including 1-Octen-3-ol, have been reported to inhibit the growth of pathogenic fungi, including Botrytis cinerea and Lecanicillium fungicola that infect plants and commercial mushrooms, respectively5,6. Additionally, the fungal volatilome can also modulate the tri-trophic interactions between fungi, plants, and insects, making the host plants more susceptible to arthropod herbivory7. In di-trophic fungal-insect interaction, the C-8 fungal VOCs are thought to act as chemical signaling molecules that elicit behavioral responses in insects to aid the establishment of symbiotic relationships or escape from the fungivory, thereby increasing their competitive survival rates8,9.

Considering the infochemical function of VOCs for shaping the inter-/intra-species fungal interactions, C-8 VOCs have been reported to inhibit conidia germination and mycelial growth in Ascomycetes, through reversibly inducing microcycle conidiation with altered membrane permeability and intracellular pH10–12. Previously, we have reported the VOCs mediated intra-species interactions between A. oryzae strains used as inocula (trivially: nuruk) in artisanal soy food fermentation13,14. We observed that the C-8 VOCs (1-Octen-3-ol, 3-Octanone, and 2-Octenal) were the most abundant and likely influenced the growth, sclerotia development, enzymes secretion, and the metabolite profiles among the interacting A. oryzae strains. Notably, the sclerotia development also serves as marked phenotype in some toxicogenic strains of A. flavus, where this morphological transformation and secondary metabolism, including aflatoxin biosynthesis are closely linked through global regulator genes like laeA and veA15. A. flavus has been reported to exhibit reduced aflatoxin production, coupled with decreased sclerotial formation, in response to exogenously induced oxidative stress, which prevents its timely morpho-transformation16. Furthermore, reduced mycelial growth, coupled with enhanced conidiation and aflatoxin biosynthesis in response to abiotic stress factors, such as visible light has been reported for A. flavus17.

Though 1-Octen-3-ol is ubiquitous and its importance in the context of the growth and development of Aspergillus species is well-recognized, the mechanisms linking its semiochemical function to its specific effects on secondary metabolism in fungi, are largely unknown. In this study, we explored the effects of 1-Octen-3-ol gradients on growth, conidiation, morpho-transformation, enzyme secretion, secondary metabolism, and the overall virulence of A. flavus. We also aimed to estimate the likely interactions of Aspergillus in specific fermented food matrices, where the C-8 VOCs are produced and shared among inoculated molds, for example, between A. oryzae and toxicogenic contaminant species such as A. flavus.

Results

C-8 VOCs in A. oryzae headspace volatilome influence A. flavus development

Previously, we have reported that C-8 compounds were the most abundant VOCs in the headspace of A. oryzae13. Herein, we first examined the production profiles of C-8 VOCs in the A. oryzae headspace during its twin-plate incubation (7–9 days) with partner strain A. flavus (plate 1). Overall, we identified eight different C-8 VOCs namely 1,3-Octadiene; 1,5-Octadien-3-ol; 1-Octen-3-ol; 3-Octanone; Octanal; 2-Octenal; 1-Octanol; and 2,4-Octadienal. The VOCs were characterized by matching their chromatographic characteristics (retention time, RT) and the pattern of mass fragment ions with available databases, in house library, and the standard compounds used in the present work. Most notably, 1-Octen-3-ol displayed the highest relative abundance and quantified as 4.53 folds on 7-day and 3.86 folds on 9-day of incubation compared to internal standard (Fig. 1a). Pertaining to the significantly higher abundance and associated info-chemical functions of 1-Octen-3-ol, we focused on determining its absolute yield during the in vitro Aspergillus interactions in twin-plate assembly. The targeted quantitative analyses of A. oryzae headspace volatilome indicated that the freshly harvested culture produced approximately 3.40 ± 1.19 ppm/h of 1-Octen-3-ol on 7-day of incubation. Since the observed yield of the VOC was recorded for the mycelial biomass following the 1 h post-harvest incubation, we extrapolated the 1-day yield to approximately 82 ppm/day. However, the 1-Octen-3-ol production rate was reduced to 2.82 ± 0.88 ppm/h on 9-day indicating an intra-day yield of 68 ppm/day (inset of Fig. 1a).

Figure 1.

Figure 1

Open in a new tab

(a) The time-correlated (7 and 9 days) relative abundance of C-8 VOCs and the absolute production yield of 1-Octen-3-ol (inset) in the headspace volatilome of A. oryzae incubated in plate 2 (P2: source of VOCs) of twin-plate. Effects of treatment 1 (T1—A. oryzae volatilome) on the developmental phenotypes (b) radial growth rates, Kr (c) sclerotial counts, Sc (d) conidial density, Cd and (e) the secreted α-amylase activity, Aa of A. flavus incubated in plate 1 (P1: sink of VOCs) during the twin-plate experiment. The statistical significance between the phenotype observations were evaluated using one-way ANOVA with Duncan's multiple range tests at *p < 0.05 and **p < 0.01. The data represents the mean value for three biological replicates with error bars indicating the standard deviation.

Further, we examined the effects of A. oryzae volatilome with the highest relative abundance of 1-Octen-3-ol (treatment 1; T1) on the growth and developmental phenotypes of A. flavus incubated in plate 1 (P1) of twin-plate assembly. On 7-day of incubation, we recorded the significantly lower radial growth rate (Kr) and sclerotial count (Sc) coupled with marginally lower conidial density (Cd) and the significantly higher secretory amylase activity (Aa) for A. flavus subjected to T1, compared to the untreated sets at p < 0.01 (Fig. 1b–e). However, the 9-day incubated A. flavus displayed marginally lower Kr with significantly lower Sc and Cd coupled with significantly higher Aa compared to untreated sets at p < 0.01. Taken together, these results indicate that 1-Octen-3-ol which constitutes the largest proportion of C-8 VOCs in the A. oryzae volatilome may have affected A. flavus development while its twin-plate incubation.

Exposure to the gradient titers of 1-Octen-3-ol influence A. flavus development

We assumed that the temporal production dynamics of 1-Octen-3-ol must be higher than the calculated yield owing to the probable random errors that may have arisen during the multi-step process involving sample harvest from twin-plate, biomass transfer into SPME vial, altered physicochemical conditions during post-harvest incubation in Ringer's solution, VOC extraction, and instrument analysis18. Hence, we considered the higher concentration gradients (> 100 ppm) of standard 1-Octen-3-ol toward examining its potential effects on A. flavus developmental phenotypes (growth, sclerotia morphogenesis, conidiation, and amylase production).

Most notably, we observed an inverse correlation between the 1-Octen-3-ol gradient treatment (T2) and A. flavus growth. The twin-plate exposure of A. flavus to the increasing titers of 1-Octen-3-ol resulted in the following order of growth rates (Kr); untreated > T2 100 ppm/day > T2 200 ppm/day > T2 400 ppm/day on 7-day of incubation (p < 0.01). Similar trends were evident for the Kr values from 9-day incubated A. flavus except for a time-correlated increase in overall growth rates (Fig. 2a). Considering the morpho-transformation as an important stage in A. flavus growth cycle, we investigated the effects of 1-Octen-3-ol gradient exposure on sclerotia formation. Intriguingly, we observed the reciprocal trends for the total sclerotial counts (Sc) in A. flavus subjected to the increasing concentration gradients of 1-Octen-3-ol. The Sc varied significantly between the treated (T2) and untreated samples (p < 0.01), with the following trend; untreated > T2 100 ppm/day) > Sc T2 200 ppm/day > Sc T2 400 ppm/day, on 7 and 9-day of incubation (Fig. 2b).

Figure 2.

Figure 2

Open in a new tab

Effects of treatment 2 (T2—1-Octen-3-ol gradients) on the developmental phenotypes (a) radial growth rates, Kr (b) sclerotial counts, Sc (c) conidial density, Cd and (d) the secreted α-amylase activity, Aa of A. flavus incubated in plate 1 (P1: sink of VOCs) during the twin-plate experiment. The data represent the mean for three biological replicates with error bars indicating the standard deviation. The statistical significance between the observations were evaluated using one-way ANOVA with Duncan's multiple range tests at *p < 0.05 and **p < 0.01.

The standard VOC treatments varyingly influenced the conidia formation in A. flavus depending upon the different titers of 1-Octen-3-ol treatments (Fig. 2c). On day 7 of incubation, A. flavus exposed to lower titers (T2 100–200 ppm/day) of standard 1-Octen-3-ol displayed significantly higher conidial density (Cd) compared to the corresponding treatment with its higher titers (T2 400 ppm/day) as well as the untreated sets, (p < 0.01). Intriguingly, we observed a critical threshold of 1-Octen-3-ol treatment where its varying concentrations, i.e., ≤ 200 ppm/day and 400 ppm/day resulted higher and lower Cd, respectively. However, the Cd values for 9-day incubated treated sets (T2 100–400 ppm/day) were significantly lower compared to the untreated sets (p < 0.01).

Secretory α-amylase production is considered as the function of A. flavus ability to colonize host surfaces (especially the plants) and its virulence19. Notably, the higher α-amylase activities (Aa) were observed for A. flavus following the 1-Octen-3-ol gradient treatments in the following order; T2 200 ppm/day > T2 400 ppm/day > T2 100 ppm/day > untreated, on 7-day of incubation (Fig. 2d). However, the α-amylase production was considerably decreased in all the treated as well as control sets on 9-day of incubation. These observations are consistent with our earlier report suggesting the higher extracellular secretion of hydrolytic enzymes in Aspergillus species following the VOCs exposure, including the C-8 alcohols13.

Exposure to 1-Octen-3-ol influence secondary metabolite profiles in A. flavus

Having established that 1-Octen-3-ol affects the normal course of growth and development in sclerotia forming strain of A. flavus, we examined its effects on associated secondary metabolite profiles. The multivariate analyses based on UHPLC-LTQ-Orbitrap-MS datasets displayed considerable disparity in the secondary metabolite profiles of A. flavus exposed to A. oryzae volatilome (T1) as well as the varying gradients of 1-Octen-3-ol (T2) in the twin plate assembly. The unsupervised principal component analysis (PCA) score plot indicated clearly distinct patterns of secondary metabolite profiles for A. flavus subjected to different VOC treatments. Notably, the datasets for 7-day incubated A. flavus exposed to A. oryzae volatilome (T1) as well as the untreated sets displayed clustered profiles segregated across PC2 (10.67%) from those subjected to 1-Octen-3-ol gradient treatments (T2). Further, the metabolite profile datasets for A. flavus (7-day) subjected to T1 were segregated across PC1 (18.03%) from those observed for treatment sets T2 and the untreated (Fig. 3a). However, the metabolite profiles for 9-day incubated A. flavus showed only two major dataset clusters, with all treatments sets (T1 and T2) clustered and segregated from the untreated groups across PC1, suggesting a time correlated and transient effect of 1-Octen-3-ol exposure (Fig. 3a).

Figure 3.

Figure 3

Open in a new tab

The multivariate score plots (a) PCA, (b) PLS-DA and (c) the heat-map for the relative abundance of significantly discriminant metabolites (VIP > 0.7 and p < 0.05), based on the UHPLC-LTQ-Orbitrap-MS datasets. The data highlights a marked disparity in the secondary metabolite profiles of A. flavus subjected to varying VOC treatments (T1 and T2) compared to the untreated sets, on 7 and 9 days of incubation during twin-plate experiment.

Similar to PCA, the supervised partial least squares—discriminant analysis (PLS-DA) indicated a marked variability in the metabolite profiles of VOC treated (T1 and T2) A. flavus with an overall variance of 28.47% (PLS1 = 17.92% and PLS2 = 10.55%), high predictive ability (Q2Y = 0.86), goodness of fit (R2X = 0.51 and R2Y = 0.98), and considerable significance metric (p = 0.0003), as indicated in Fig. 3b. We selected the significantly discriminant metabolites contributing maximally to the observed variance in the metabolite profiles of VOC treated A. flavus based on the variable importance in projection (VIP) > 0.7 and p < 0.05 in the respective PLS-DA model (Table 1). Altogether, we observed 32 significantly discriminant secondary metabolites falling under different chemical classes, including alkaloid (1), xanthone (2), coumarin (3), anthraquinones/ quinones (4–9), indole/ indole-terpenes (10–12), fatty acid derivatives/ oxylipins (13–18), miscellaneous compounds (19–21), and the non-identified metabolites (22–32). Considering the importance of secondary metabolites in shaping the fungal trophic interactions and stress response, we quantitatively expressed their time correlated relative abundance using the heat map (Fig. 3c). Notably, we observed an approximately two-fold higher relative abundance of polyketide (PK) mycotoxin, aflatoxin B1, and its precursors compounds (5-methoxysterigmatocystin, versicolorin A, and averufin except versicolorin B) for 7-day incubated A. flavus subjected to 1-Octen-3-ol gradient treatments (T2). However, the relative abundance of non-ribosomal peptide (NRP) mycotoxins including α-cyclopiazonic acid and paxilline decreased considerably in both the treatment groups T1 and T2 on 7-day. Further, some of the anthraquinone compounds, including asparasone A, displayed lower relative abundance in VOC- treated groups (T1 and T2) compared to the untreated samples of A. flavus on 7-day.

Table 1.

List of the significantly discriminant metabolites selected using the PLS-DA model (VIP > 0.7 and p < 0.05) based on the UHPLC–LTQ–Orbitrap–MS datasets for A. flavus extracts following the VOC treatments.

No. RT (min) Tentative metabolites [M + H]+ [M − H]‒ M.W Elemental composition Error (ppm)a MSn fragment pattern p value References
Alkaloid
1 5.63 Aspergilline C 441.2026 439.1951 440 C24H29N2O6 (+) 1.353 (+) 441 > 291, 265 > 177 5.00E−06 Uka et al.50
Xanthone
2 5.86 5-Methoxysterigmatocystin 355.0819 353.0728 354 C19H15O7 (+) 1.917 (−) 353 > 338 > 323, 310 > 295, 279 1.23E−03 Carvajal-Campos et al.51
Coumarin
3 6.12 Aflatoxin B1 313.0710 311.0619 312 C17H13O6 (+) 1.007 (+) 313 > 285 > 270, 257 > 253, 242 2.39E−02 Carvajal-Campos et al.51
Anthraquinones/ quinones
4 6.55 Asparasone A 381.0583 357.0673 358 C18H14O8Na (+) 0.686 357 > 339, 299 3.00E−05 Carvajal-Campos et al.51 and Malysheva et al.52
5 6.72 Anthraquinone derivative 1 269.0804 267.0796 268 C16H13O4 (+) − 1.804 267 > 252 > 223, 208 > 195 3.90E−05 Fouillaud et al.53
6 7.10 Anthraquinone derivative 2 ‒ 315.0555 316 C16H11O7 (‒) 5.409 315 > 297 > 269, 253 > 241, 225 0.00E+00 Fouillaud et al.53 and Carvajal-Campos et al.51
7 5.56 Chrysophanol 255.0657 253.0551 254 C15H11O4 (+) 1.743 (+) 255 > 237, 227, 199 > 181, 171 > 153 (−) 253 > 253, 224, 209, 185 1.00E−06 Tripathi et al.54
8 7.26 Versicolorin B 341.0656 339.0558 340 C18H13O7 (+) 0.178 339 > 321, 311, 297 > 295, 269, 253 0.00E+00 Carvajal-Campos et al.51
9 7.94 Versicolorin A 339.0504 337.0410 338 C18H11O7 (+) 1.330 337 > 309 > 281, 265 > 252 1.71E−02 Carvajal-Campos et al.51
Indole/ Indole terpenes
10 7.61 Sulpinine C 536.3008 534.2937 536 C32H42NO6 (+) − 1.258 534 > 476 > 416 > 400, 358 6.50E−05 Laakso and Gloer55
11 8.13 α-Cyclopiazonic acid (CPA) 337.1545 335.1450 336 C20H21N2O3 (+) − 1.095 335 > 180, 154, 140 1.10E−03 Uka et al.50
12 8.72 Paxilline 436.2480 434.2399 435 C27H34NO4 (+) − 0.080 434 > 415, 346 > 331, 316, 302 2.70E−05 Carvajal-Campos et al.51
Fatty acid derivatives/ oxylipins
13 6.44 9,12,13-TriHOME 353.2305 329.2383 330 C18H34O5Na (+) 1.938 (−) 329 > 311 > 293, 229, 211, 199, 171 8.60E−05 Singh and Lee13 and Son et al.56
14 7.04 Fatty acid derivative 295.2262 293.2164 294 C18H31O3 (+) − 1.834 (−) 293 > 275, 235 > 231, 177 1.05E−02 CHCD
15 7.51 5,8-DiHODE 335.2192 311.2270 312 C18H32O4Na (+) − 3.483 (−) 311 > 293, 275, 173 > 249, 231 1.79E−03 Singh and Lee13
16 7.84 12,13-DiHOME(9) 337.2350 313.2433 314 C18H34O4Na (+) − 2.899 (−) 313 > 295 > 277, 259, 251, 233 0.00E+00 Singh and Lee13; Standard compound
17 8.00 Dihydroxy-octadecadienoic acid (DiHODE) 335.2191 311.2274 312 C18H32O4Na − 0.479 (−) 311 > 293, 275, 211, 187, 171, 157 4.10E−05 Son et al.56; CHCD
18 9.41 Fatty acid derivative 297.2422 295.2322 296 C18H33O3 (+) − 0.678 (−) 295 > 277, 251 > 233, 179, 165, 139 0.00E+00 CHCD
Miscellaneous
19 7.75 Aspergilone A 387.1931 431.1896 386 C26H27O3 (+) − 6.176 (+)387 > 331 > 275, 231, 175 0.00E+00 Shao et al.57
20 7.84 Aszonapyrone A 457.2947 455.2870 456 C28H41O5 (+) − 0.242 455 > 437, 411, 393 > 375, 325, 287, 269 2.23E−04 Kimura et al.58
21 9.16 Averufin 391.1653 367.0869 368 C20H15O7 (‒) 4.696 367 > 349, 323, 267 > 223 2.00E−06 KNApSAcK core system
Non-identified
22 5.14 N.I. 1 445.2339 443.2264 444 C24H33N2O6 (+) 0.464 445 > 267, 250 > 179, 137 2.00E−06 ‒
23 5.20 N.I. 2 246.1129 244.1025 245 C14H16NO3 (+) 1.748 246 > 228 > 200 > 183, 133 4.00E−06 ‒
24 6.47 N.I. 3 525.2715 523.2636 524 C27H41O10 (+) 4.048 523 > 417 > 311 > 267 0.00E+00 ‒
25 7.17 N.I. 4 548.2863 546.2801 547 C29H42NO9 (+) 1.663 546 > 417, 311 2.36E−04 ‒
26 7.77 N.I. 5 ‒ 339.0558 ‒ C11H15O12 (‒) − 3.183 ‒ 2.78E−04 ‒
27 7.98 N.I. 6 532.2917 530.2847 531 C25H42N2O10 (+) − 0.365 530 > 401 > 383, 357, 285 > 203, 179 1.04E−04 ‒
28 9.25 N.I. 7 581.2431 579.2350 580 C23H42O15Na (+) − 0.238 579 > 523, 417 > 347, 149 0.00E+00 ‒
29 9.45 N.I. 8 540.4253 538.4178 539 C31H58NO6 − 1.841 538 > 519, 494, 450, 408, 337, 355 4.16E−04 ‒
30 10.40 N.I. 9 669.3312 667.3269 668 C41H47O8 (‒) − 0.377 667 > 637 > 619, 431, 369 > 351, 267, 225 2.05E−03 ‒
31 10.59 N.I. 10 637.3049 681.3083 636 C27H47N3O14 (+) − 0.415 681 > 653 > 447 > 285 > 267 2.24E−03 ‒
32 11.25 N.I. 11 637.3063 635.2993 636 C27H47N3O14 (+) − 0.415 635 > 367 > 337, 267, 149 0.00E+00 ‒
Open in a new tab

RT: Retention time for chromatographic elution. CHCD: Combined Chemical Dictionary, Chapman and Hall, London, UK, 1992.

aMass tolerance from elemental composition analysis.

We observed marked variations in the relative abundance of oxylipin compounds following the growth and morpho-transformation changes in response to the VOCs treatments. Following the 7-day of incubation, all oxylipin compounds except 9,12,13-trihydroxy-10E-octadecenoic acid (9,12,13-TriHOME) were significantly reduced for VOC treated groups (T1 and T2) compared to the untreated sets. Intriguingly, A. flavus exposed to the lower titers of 1-Octen-3-ol (T2; 100 and 200 ppm/day) displayed approximately two-fold higher relative abundance of oxylipins compared to those exposed to its higher titers (T2; 400 ppm/day) as well as the A. oryzae volatilome (T1) on 9-day. The patterns of observed variation in the relative abundance of oxylipin compounds coupled with reduced sclerotia formation (Fig. 2b) suggests their intricate role in modulating A. flavus response to 1-Octen-3-ol gradient treatments.

Further, aspergilone A and the non-identified (N.I) metabolites except N.I. 3 and N.I. 5 were observed more abundant in the VOCs treated (T1 and T2) A. flavus compared to the untreated samples. These trends were coupled with the reduced growth rates and sclerotial counts in the respective treatments on 7-day of incubation. However, we observed reverse trends for the 9-day incubated samples with most of the uncharacterized metabolites (N.I. 4 and N.I. 7–11) being less abundant in A. flavus subjected to T2 as compared to T1, which suggests the distinctive effects of standard 1-Octen-3-ol gradients and A. oryzae volatilome with a blend of C-8 VOCs.

Correlations among the 1-Octen-3-ol exposure treatments, developmental phenotypes, and metabolite profiles for A. flavus

We argue that the controlled exposure of A. flavus to the 1-Octen-3-ol sources might have influenced its developmental phenotypes (growth, conidiation, sclerotia morphogenesis, and extracellular secretion of amylases) coupled with subtle metabolite levels. Hence, we evaluated the statistical correlation networks (Pearson's coefficient r, 0.4 > and <  − 0.4; p < 0.01) among the 1-Octen-3-ol treatments, the A. flavus phenotypes, and the associated metabolite abundance, individually in each case (Fig. 4). Notably, the exposure to 1-Octen-3-ol gradients to A. flavus was positively correlated with mycotoxins production including aflatoxin B1 and its precursors (5-methoxysterigmatocystin, versicolorin A, averufin), and an anthraquinone compound chrysophanol. Further, we observed negative correlations between the 1-Octen-3-ol treatments and the relative abundance of oxylipin compounds (Fig. 4a). Intriguingly, the higher relative abundance of PK mycotoxins coupled with the lower levels of oxylipin compounds concurred with the reduced growth rates and sclerotia formation in VOC treated A. flavus, most notably on 7-day.

Figure 4.

Figure 4

Open in a new tab

The spring-embedded network indicating the individual correlations between the significantly discriminant secondary metabolite levels and (a) the 1-Octen-3-ol gradient treatments, Tgrad. (b) mycelial growth rates, Kr (c) conidial density, Cd (d) sclerotial counts, Sc and (e) secreted α-amylase activity, Aa for A. flavus subjected to varying VOC treatments. The nodes of the network represent the metabolites indicated with unique codes while the edges display the significant correlations (Pearson's coefficient r, 0.4 > and <  − 0.4 at p < 0.01) for multiple testing. The positive and negative correlations are indicated with red and blue colored nodes, respectively.

Focusing on A. flavus developmental phenotypes following the VOC treatments, the radial growth rates (Kr, mm2/day) displayed significantly positive correlations with certain anthraquinone compounds (asparasone A and anthraquinone derivative 2), indole-terpene NRP mycotoxins (α-cyclopiazonic acid and paxilline), oxylipin compounds (12,13-dihydroxy-9-octadecenoic acid (12,13-DiHOME) and dihydroxy-octadecadienoic acid), a quinone compound (versicolorin B), and a meroditerpene alkaloid (aszopyrone). Conversely, the negative correlations were evident between mycelial growth and aspergilline C (a CPA-derived NRP mycotoxin), chrysophanol (antraquinone), oxylipin 9,12,13-TriHOME, and aspergilone A (di-terpenoid) as displayed in Fig. 4b. The mycelial transformation to sclerotia displayed strong positive correlations with most oxylipin compounds except 9,12,13-TriHOME suggesting their intertwined functional role in A. flavus development and morpho-transformation (Fig. 4c). In addition, positive correlations were evident between sclerotia formation and its characteristic pigment compound, i.e., asparasone A (anthraquinone), which imparts dark-brown coloration during their later stages of development20. Further, positive correlations were also observed for an anthraquinone compound, a quinone aflatoxin precursor (versicolorin B), and an NRP-derived indole terpene mycotoxin (paxilline). On the other hand, sclerotia formation showed negative correlations with most of the anthraquinone compounds (except asparasone) including aspergilline C and aspergilone A as well as the non-identified (N.I.) metabolites. The conidial density variation in VOC treated A. flavus (Fig. 4d) displayed strong positive correlations with oxylipin compounds (5,8-dihydroxy-9,12-octadecadienoic acid (5,8-DiHODE), 12,13-DiHOME, and dihydroxy-octadecadienoic acid) in agreement to the previous reports suggesting their functional roles21,22. However, negative correlations were observed between conidia development and an oxylipin compound 9,12,13-TriHOME, anthraquinone compounds (derivative 1 and chrysophanol), and the indole terpene mycotoxins (paxilline and aspergilline C).

The extracellular secretion of hydrolytic enzymes and biosynthesis of secondary metabolites, especially the mycotoxins, analogously complement the A. flavus colonization on host surfaces23. We observed that the trends of amylase activity in VOC treated A. flavus showed positive correlations with selected secondary metabolites including aspergilline C, certain quinone/anthraquinones (chrysophanol and derivative 1), oxylipins (9,12,13-TriHOME and fatty acid derivative 1), diterpenoid compound aspergillone A, and most of the N.I compounds (Fig. 4e). Conversely, negative correlations were evident between the secreted amylase activity and quinone/anthraquinones (derivative 1, asparasone A, and versicolorin B), indole terpenes (sulpinine C, CPA, and paxilline), some oxylipin compounds (5,8-DiHODE and DiHODE), and meroditerpene compound aszonapyrone A.

Discussion

The VOCs mediated interactions among the Aspergillus species under section Flavi including those between A. flavus and A. oryzae are conserved as they colonize the common niche environment ranging from field crops to fermented foods24–26. Hence, we examined the effects of A. oryzae volatilome, narrowing down to infochemical compound 1-Octen-3-ol, on toxicogenic A. flavus strain using an indigenously designed twin-plate assembly. First, we sought to identify the C-8 VOCs and evaluated their time-correlated relative abundance in the A. oryzae headspace that may have influenced the developmental and metabolic changes in A. flavus. The biosynthesis of C-8 VOCs is associated with the enzymatic oxidation and lysis of linoleic acid which influence the fungal development through the production of short-chain functional oxylipins12,27,28. Herein, we observed the highest relative abundance of 1-Octen-3-ol followed by 2-Octenal, and 3-Octanone among others in the A. oryzae headspace volatilome. Considering the significantly higher proportions of 1-Octen-3-ol in A. oryzae volatilome and its role in Aspergillus development, we explored it potential signaling functions in mediating ‘A. oryzae – A. flavus’ interactions10–12,29,30. We observed a concentration dependent decrease in mycelial growth of A. flavus following the 1-Octen-3-ol exposure treatments, most notably on 7-day of incubation (Figs. 1b, 2a, and Supplementary Fig. S1). These results are congruent to the previous reports suggesting the fungicidal (~ 50–100 ppm) as well as fungistatic (~ 5–10 ppm) effects of 1-Octen-3-ol on Ascomycetes fungi, Pseudogymnoascus destructans, while cultivation in partitioned bi-petri plates31.

In some A. flavus strains, the mycelial growth is followed by the onset of two developmental phenomena namely sclerotia morphogenesis and conidiation. These two stages of A. flavus development are believed to be reciprocally regulated by common regulatory genes, VeA and LaeA15,20. Accordingly, we observed lesser sclerotial counts coupled with higher conidial density for A. flavus subjected to 1-Octen-3-ol gradient exposure (T2100-200 ppm/day) on 7-day, compared to the untreated strains (Figs. 1c, 2b). Further, we observed an inverse relation between the increasing titers of 1-Octen-3-ol and the total sclerotial counts, suggesting the morpho-transformation inhibitory effects of the C-8 VOCs, in agreement to our previous study13. Although an inverse correlation was valid for 1-Octen-3-ol gradient treatments and morpho-transformation on 9-day, a marked increase (~ 150–300%) in sclerotial counts suggests both the A. flavus resilience as well as the transient nature of 1-Octen-3-ol impact. Notably, the lowest sclerotial counts were observed for A. flavus exposed to A. oryzae volatilome which suggests the synergistic effects of C-8 VOC blends.

Evaluating the effects of VOC treatments (T1 and T2) on conidiation, we observed lower conidial density for A. flavus subjected to higher titers (400 ppm/day) of 1-Octen-3-ol and A. oryzae volatilome compared to the untreated samples. In contrast, significantly higher conidial density (p < 0.01) values were evident for the strains treated with lower titers (≤ 100–200 ppm/day) of the standard VOC. Hence, we suggest a ‘critical threshold titer (x)’ at which the A. flavus exposure to the 1-Octen-3-ol gradients (≤ 200 ppm/day, x, ≥ 400 ppm/day) may induce ambiguous effects on conidiation pattern (Figs. 1d, 2c). Previously, Chitarra et al.10,11 have suggested that 1-Octen-3-ol may reversibly induce microcycle conidiation or conidia budding through circumventing their hyphal transformation to conidiophore formation stage in Penicillium paneum. However, the 9-day incubated untreated strains displayed higher conidial density as compared with those subjected to VOC treatment, which suggests the transient and time-correlated nature of 1-Octen-3-ol mediated effects on A. flavus development. We argue that the twin-plate exposure to sub-critical threshold titers (x ≤ 200 ppm/day) of 1-Octen-3-ol may reversibly alter the developmental shift in A. flavus toward microcycle conidiation.

The saprophytic growth of A. flavus in its ecological niche is facilitated by secretory hydrolases, where the α-amylase mainly degrades the host tissue polysaccharides and thus influence the fungal trophic interactions19,32. Considering the Aspergillus development, the secretion of amylases is interfered by the higher conidiation rates, where the two phenomena are reciprocally regulated by a cascade of genes including flbA, brlA, and fluG33. However, we observed a significantly higher α-amylase activity coupled with higher conidial density in A. flavus subjected to 1-Octen-3-ol exposure at sub-critical threshold titers (x ≤ 200 ppm/day). The observed anomaly can be attributed to the simultaneous induction of enhanced membrane permeability and microcycle conidiation by 1-Octen-3-ol treatments, as suggested previously by Chitarra et al.10,11. However, the A. flavus exposure to critical threshold titers (x ≥ 400 ppm/day) of 1-Octen-3-ol affected lower conidial density coupled with higher amylase secretion compared to the untreated sets (Fig. 2d). We hypothesize that the critical threshold titers of 1-Octen-3-ol may reversibly arrest the A. flavus development (growth, morphogenesis, and conidiation), which prompts fungi to enhance hydrolytic enzymes secretion for sequestering more nutrients. Previously Hu et al.34 have pointed out that A. flavus deletion mutant for some transcription factor (ΔRum1) displays epigenetic perturbations which modulates altered sclerotia-conidia balance, coupled with enhanced amylase secretion and aflatoxicosis.

An increasing number of studies have emphasized that microbial interaction including those mediated by signaling VOCs may trigger the cryptic biosynthetic pathways shaping their chemical ecology35–37. Especially, the mycotoxins are increasingly been recognized as 'fitness factors' influencing the fungal virulence and hence their ecological interactions in nature38. In the present study, we observed a marked disparity in the relative abundance of secondary metabolites for A. flavus subjected to VOC treatments, as displayed in Fig. 3. It is most noteworthy that 1-Octen-3-ol treatments significantly enhanced PK mycotoxin, aflatoxin B1, and its precursor compound biosynthesis in the sclerotia forming strain of A. flavus (Fig. 3c). The spring embedded correlation map analyses unraveled strong positive correlations between the 1-Octen-3-ol treatments and polyketide mycotoxin compounds (Fig. 4a). Recently, Pennerman et al.29 have also reported the upregulated production of PK mycotoxin 'patulin' in P. expansum subjected to sub-inhibitory levels of 1-Octen-3-ol exposure, which suggest its potential signaling function to induce the stress response in fungi. We propose that the heightened mycotoxin production determines the competitive fitness of interacting species where the potential ammensalic interactions are being shaped. The C-8 VOCs reportedly affected the oxidative stress condition on interacting species which may lead to heightened aflatoxin B1 production through various mechanisms39. However, the terpenoid derived NRP mycotoxins including α-cylopiazonic acid (CPA) and paxilline displayed significantly lower abundance in VOC treated (T1 and T2) sets, which suggests a selective metabolic response of A. flavus to the specific VOC (Fig. 3c). Another important class of secondary metabolites perturbed following the VOC treatments (T1 and T2) were anthraquinones, which are directly linked with the developmental phenotypes including growth, conidiation, and sclerotia formation in fungi (Figs. 3, 4). Functionally, the anthraquinone derivative ‘asparasone A’ is important for sclerotia pigmentation, which marks an important step in the life cycle of sclerotia forming fungi21,40.

The fungal oxylipin constitutes a wide spectrum of short chain (~ C6 – C9) volatiles compounds and the long chain (~ C16—C20) secreted molecules produced through LOX (lipoxygenase) activity, which altogether modulates its quorum sensing mechanism and associated development22,41. In particular, the linoleic acid (C18:2) derived oxylipins are known to regulate a balance between ‘conidia-sclerotia’ formation depending on cell density in A. flavus cultures42. Similarly, the C-8 volatile oxylipin ‘1-Octen-3-ol’ is reported to induce quorum sensing under high conidial density conditions in Penicillium species, inhibiting its normal course of conidia germination10–12. Herein, a lower relative abundance of most oxylipin compounds except for 9,12,13-TriHOME was evident for VOC-treated A. flavus on 7-day of incubation (Fig. 3c). However, strong positive correlations were evident between the oxylipin abundance and A. flavus phenotypes (Fig. 4b–d) being altered following the VOC treatment, which signifies their pivotal role in modulating Aspergillus development. Further, we observed a number of uncharacterized (N.I) metabolites as well as the miscellaneous ones showing marked perturbation and statistical correlations with developmental phenotypes in VOC treated A. flavus (Figs. 3c, 4). In particular, the di-terpenoid derivatives including aspergilone A and sulpinine C, meroterpenoid derivative aszopyrone A, CPA derivative aspergillin C, and anthraquinone compound chrysophanol have largely uncharacterized functions during the Aspergillus development.

In the present study, we propose that the critical threshold titers of 1-Octen-3-ol in the A. oryzae headspace may elicit a developmental response in A. flavus characterized by reduced growth, delayed morpho-transformation, and altered conidiation patterns. Intriguingly, the attenuated development in A. flavus was coupled with the heightened production of secretory α-amylases and PK mycotoxins. We examined a few secondary metabolite classes including alkaloids, coumarins, anthraquinones, indole terpenoids, and oxylipins perturbed following the VOC treatment in A. flavus. The present study illustrates how the gradient treatment with C-8 VOC ‘1-Octen-3-ol’ may influence interspecies Aspergillus interactions through providing an insight into the metabolomic shift in A. flavus. Although these interactions are hard to extrapolate for complex microbiomes in environment, we can hypothesize such interactions in relatively simple semi-natural environs like fermented foods, stored commodities, laboratory cultivations systems, or even the indoor building environs43–45. Herein, we determine the potential role of 1-Octen-3-ol in modulating the A. flavus development and its inter-species interactions which may help in designing the effective strategies toward aflatoxin management.

Methods

Chemicals

Analytical grade (≥ 98.0%) R enantiomer of 1-Octen-3-ol standard compound was purchased from Sigma-Aldrich). Solvents including HPLC grade acetonitrile, methanol, ethyl acetate, hexane, and di-chloromethane were purchased from Fisher Scientific (Waltham, MA, USA).

Fungal cultures and cultivation

The Aspergillus flavus KCCM 11899 and A. oryzae KCCM 60345 were procured from the 'Korean Culture Center of Microorganisms (KCCM)' at the National Academy of Agricultural Sciences, Seodun-dong, Suwon, Republic of Korea. The fungi were sub-cultured and maintained (14 days, 30 °C) in malt-extract agar (MEA) for harvesting fresh spores toward inoculation. A fixed conidia suspension of 10 μL (1 × 106 spores/mL) was centrally inoculated in WATM agar for all experimental and control sets13. The conidia counting in all steps of experiment was performed using Neubauer haemocytometer.

Headspace—solid phase microextraction (HS-SPME) for A. oryzae (P2—source of VOCs)

We harvested the mycelial biomass for 7-day and 9-day incubated A. oryzae samples from plate 2 (treatment 1) in Ringer's solution (10 mL), using the method partially adapted from Singh and Lee13 and Costa et al.46. The freshly harvested samples were added with sodium chloride (0.2 g/mL) toward better extraction of VOCs through reducing their solubility in Ringer's solution. Standard compound 'linalool' (1 ppm) was added as the internal standard (IS) and the harvested samples were transferred to 20 mL SPME vial (Merck KGaA, Germany) with septum closed. At this step, the freshly harvested biomass was further incubated for 1 h under the experimental conditions so that VOCs from the physiologically active culture may accumulate in closed SPME vials. Three biological replicates of A. oryzae were subjected to headspace (HS) VOC extraction using divinylbenzene/carboxen/polydimethylsiloxane (DVB-CAR-PDMS) StableFlex (1 cm) fiber (Sigma-Aldrich) for 60 min at 65 °C with intermitted agitation (100 rpm) on L-PAL3 GC autosampler (LECO Corporation, St. Joseph, MI, USA).

We maintained three biological replicates for each of the sample harvested. The absolute quantities of 1-Octen-3-ol were determined using the linear least square regression analysis of the standard curve (linear range 0.5–6.5 ppm) with three analytical replicates. The standard compound gradients were first added in 10 mL Ringer's solution with NaCl (0.2 g/mL) and subjected to the same extraction steps as described for the A. oryzae volatilome.

A. flavus exposure to A. oryzae volatilome (treatment 1) and the standard VOC gradients (treatment 2)

The effects of A. oryzae volatilome and the varying gradients of standard compounds on A. flavus development were examined using the twin-plate (P1 × P2) experiment (Fig. 5), previously designed and reported by Singh and Lee13. The plate 1 (P1—sink of VOCs) with perforated lid and extrinsic filter paper was inoculated with A. flavus and assembled face-to-face with plate 2 (P 2—source of VOCs).

Figure 5.

Figure 5

Open in a new tab

Schematics displaying the design of experiment (DOE) to examine the effects treatment 1 (T1—A. oryzae volatilome) and treatment 2 (T2—1-Octen-3-ol gradients) on A. flavus in twin-plate experiment (P1 × P2). The effects of treatments (T1 and T2) on A. flavus were compared with untreated set serving as the experimental control to normalize the baseline effects of endogenously produced VOCs. All treatments and control sets were examined maintaining the three biological replicates of each.

In treatment 1, we examined the pair-wise Aspergillus interactions through inoculating P2 with A. oryzae. The choice of A. oryzae as the partner strain as well as the source of natural volatilome was inspired by the reports describing the untoward colonization of fermented foods by the toxicogenic strains of A. flavus24–26. In treatment 2, the selective effects varying concentration gradients of 1-Octen-3-ol on A. flavus were examined using the parallel experimental sets. Briefly, following the 4 day incubation period necessary to acquire competence in A. flavus (P1), the P 2 of twin-plate was infused with varying gradients of standard 1-Octen-3-ol (100 ppm/day, 200 ppm/day, and 400 ppm/day). Another reason rationalizing the timing of standard VOC infusion was the reported onset of C-8 VOCs production in Aspergillus species after 3–4 days of incubation under aerobic conditions47. We maintained the experimental controls for treatment 1 and 2 by incubating A. flavus (P1) under the untreated conditions without any VOCs sources in P2 of twin-plate. Herein, we wish to emphasize that the untreated set will serve as the control toward observing the baseline effects of endogenously produced C-8 VOCs on the developmental phenotypes of A. flavus itself. Following the inoculation, all twin-plates were placed flat ensuring P1 (A. flavus) at the top and P2 (A. oryzae in T1 and standard compounds in T2) lay at the bottom, allowing the upward flow of low vapor pressure VOCs from P2 to P1. We maintained three biological replicates for each of the treated (T1 – A. oryzae volatilome and T2 – 1-Octen-3-ol gradients) and untreated sample, all incubated at 30 °C under dark conditions for 7- and 9-days.

VOC analyses based on Gas chromatography–time of flight–mass spectrometry (GC–TOF–MS)

The VOCs were analyzed on an Agilent 7890A system (Agilent, Santa Clara, CA, USA) coupled with Pegasus HT TOF–MS and L-PAL3 GC autosampler (Leco Corporation, St. Joseph, MI, USA). The VOCs separation was performed on RTx-5MS fused silica capillary column (30 m × 250 μm i.d., pore size 0.25 μm) purchased from J&W Scientific, Folsom, CA, USA with helium as the carrier gas at the constant flow rate of 1.5 mL/min. The extraction fiber was desorbed in GC injection port at 270 °C for 3 min and the analysis was performed in splitless mode. The column temperature was initially maintained at 45 °C for the first 9 min, ramped to 85 °C in 4 min and maintained for 3 min, further elevated to 120 °C in 2.5 min and maintained for 2 min, and finally elevated to 270 °C in 7.5 min and maintained as such for the final 2 min. The overall chromatographic run program spanned 30 min. The MS data was recorded at the rate of 100 scans per second in the m/z range of 35–300. The variance across different steps of metabolic profiling was assessed using pooled quality control (QC) sample runs intermittently. The VOCs examined using GC–TOF–MS were characterized using the standard compound comparing their RT and MS fragments. In addition, we confirmed the spectral data for VOCs with available databases including VocBinBase48 and National Institute of Standards and Technology (NIST), ver. 2.0, 2011, FairCom, USA.

Sample harvest and analyses of developmental phenotypes for A. flavus

The VOC treated and untreated sets of A. flavus were harvested following 7- and 9-days of incubations under twin-plate experiment. The A. flavus samples were immediately analyzed for growth and developmental phenotypes including radial growth rates (Kr), sclerotial counts (Sc), conidial density (Cd). Further, the fungal biomass was harvested for extracellular enzyme extraction and assayed for α-amylase activity using the protocol adapted from Chancharoonpong et al.49 and Singh and Lee14. The remaining biomass was stored under deep freezing conditions (− 80 °C), until further analyses.

Metabolite extraction

The A. flavus cultures harvested from P1 were quenched with liquid nitrogen and pulverized using pestle and mortar. The fine ground fungal biomass was subjected to metabolite extraction using the solvent mixture consisting of methanol, hexane, dichloromethane, and ethyl acetate (1:1:2:3) with 1% formic acid, while formononetin (5 mg/L) was used as the internal standard (IS). The pulverized fungal biomass was added with 20 mL of extraction solvent and the resulting mixture was subjected to overnight agitation (200 rpm) at 30 °C. The samples were sonicated for 1 h and centrifuged (10,000 × g) for 10 min to collect the supernatant. The sample supernatants were collected in scintillation vials (20 mL) and dried under speed vacuum concentrator (Hanil Scientific, Korea). The dried samples were re-suspended in extraction solvent at appropriate concentrations (10 mg/mL or 10,000 ppm) prior to the chromatographic analyses.

Metabolite profiling based on ultrahigh performance liquid chromatography–linear trap quadropole–orbitrap–mass spectrometry (UHPLC–LTQ–Orbitrap–MS)

The metabolite extracts from A. flavus subjected to varying VOCs treatment conditions in P1 of twin-plate assembly were examined using UHPLC-LTQ-Orbitrap-MS system coupled with Vanquish binary pump H system (Thermo Fisher Scientific, Waltham, Massachusetts, USA). The reverse phase chromatographic separation of metabolites was performed on Phenomenex KINETEX C18 column (100 mm × 2.1 mm, 1.7 μm particle size; Torrance, CA, USA). The mobile phase composed of water (solvent A) and acetonitrile (solvent B), were each added with 0.1% formic acid, and the flow rate was maintained at 0.3 mL/min. The 14 min gradient run program commenced with 5% solvent B for 1 min followed by its linear increase to 100% in next 9 min, maintained for 1 min, and re-equilibrated to initial condition (5% solvent B) in the final 3 min. The sample injection volume was 5 μL and the column temperature was maintained at 40 °C. The tandem MS was performed on LTQ-Orbitrap-Velospro with ion-trap (IT) MS and heated ESI or HESI-II probe (Thermo Fisher Scientific). The MS parameters were fixed at probe heater temperature of 300 °C, capillary temperature of 350 °C, and the capillary voltages of 2.5 kV (− ESI) and 3.7 kV (+ ESI). The metabolites examined using UHPLC-MS were characterized through comparing multiple parameters like retention time (RT), molecular weight (M.Wt.), elemental composition (molecular formula), and associated m/z fragmentation patterns with those retrieved comprehensively from standards, in house library, available databases, and published literatures.

Data processing and statistical analyses

The raw data files obtained from UHPLC-MS and GC–TOF–MS analyses were converted to NetCDF (network Common Data Form) file formats with .cdf extension using corresponding software packages. The files (.cdf) were preprocessed for peak list alignment, peak detection, RT, normalized peak intensities, and accurate masses comparing their full scan nominal mass using MetAlign software. The aligned data was further subjected to multivariate analyses to evaluate the class-wise variance in datasets and determining the significantly discriminant metabolites (VIP > 0.7, p < 0.05) using SIMCA-P + (version 12.0, Umetrics, Umea, Sweden). The quantitative data for phenotype analyses were subjected to pair-wise comparison based on ANOVA and Duncans/ Tukey multiple range tests using PASW statistica 18 software (SPSS Inc. Chicago, Illinois, USA). The interaction networks between varying metabolite levels and phenotypes were visualized using Cytoscape software (v3.7.2).

Supplementary information

Supplementary Information. (2.5MB, docx)

Acknowledgements

This work was supported by Korea Institute of Planning and Evaluation for Technology in Food, Agriculture and Forestry (IPET) through Agricultural Microbiome R&D Program (The Strategic Initiative for Microbiomes in Agriculture and Food), funded by Ministry of Agriculture, Food and Rural Affairs (MAFRA) (Grant Number 918011-04-3-HD020), and Traditional Culture Convergence Research Program through the National Research Foundation of Korea (NRF) funded by the Ministry of Science, ICT & Future Planning (NRF-2017M3C1B5019303).

Author contributions

D.S. and C.H.L. conceived and designed the study. D.S. performed the experiment, collected the data, and analyzed the results with the help of S.Y.S. D.S. wrote the manuscript with the inputs from S.Y.S and C.H.L. All authors read and approved the final manuscript.

Data availability

The data in this study are available from the corresponding author upon reasonable request.

Competing interests

The authors declare no competing interests.

Footnotes

Publisher's note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Supplementary information

is available for this paper at 10.1038/s41598-020-68096-x.

References

  • 1.Rowan DD. Volatile metabolites. Metabolites. 2011;1:41–63. doi: 10.3390/metabo1010041. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 2.Kanchiswamy CN, Malnoy M, Maffei ME. Chemical diversity of microbial volatiles and their potential for plant growth and productivity. Front. Plant. Sci. 2015;6:151. doi: 10.3389/fpls.2015.00151. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 3.Müller A, et al. Volatile profiles of fungi–chemotyping of species and ecological functions. Fungal Genet. Biol. 2013;54:25–33. doi: 10.1016/j.fgb.2013.02.005. [DOI] [PubMed] [Google Scholar]
  • 4.Roy, S. & Banerjee, D. Volatile organic compounds from endophytic fungi. In Recent Advancement in White Biotechnology Through Fungi, 149–175 (Springer, 2019).
  • 5.Kishimoto K, Matsui K, Ozawa R, Takabayashi J. Volatile 1-octen-3-ol induces a defensive response in Arabidopsis thaliana. J. Gen. Plant. Pathol. 2007;73:35–37. [Google Scholar]
  • 6.Berendsen RL, Kalkhove SI, Lugones LG, Baars JJ, Wösten HA, Bakker PA. Effects of the mushroom-volatile 1-octen-3-ol on dry bubble disease. Appl. Microbiol. Biotechnol. 2013;97:5535–5543. doi: 10.1007/s00253-013-4793-1. [DOI] [PubMed] [Google Scholar]
  • 7.Moisan K, Cordovez V, van de Zande EM, Raaijmakers JM, Dicke M, Lucas-Barbosa D. Volatiles of pathogenic and non-pathogenic soil-borne fungi affect plant development and resistance to insects. Oecologia. 2019;190:589–604. doi: 10.1007/s00442-019-04433-w. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 8.Cale JA, Collignon RM, Klutsch JG, Kanekar SS, Hussain A, Erbilgin N. Fungal volatiles can act as carbon sources and semiochemicals to mediate interspecific interactions among bark beetle-associated fungal symbionts. PLoS ONE. 2016;11:e0162197. doi: 10.1371/journal.pone.0162197. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 9.Holighaus G, Rohlfs M. Volatile and non-volatile fungal oxylipins in fungus-invertebrate interactions. Fungal Ecol. 2019;38:28–36. [Google Scholar]
  • 10.Chitarra GS, Abee T, Rombouts FM, Posthumus MA, Dijksterhuis J. Germination of Penicillium paneum conidia is regulated by 1-octen-3-ol, a volatile self-inhibitor. Appl. Environ. Microbiol. 2004;70:2823–2829. doi: 10.1128/AEM.70.5.2823-2829.2004. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 11.Chitarra GS, Abee T, Rombouts FM, Dijksterhuis J. 1-Octen-3-ol inhibits conidia germination of Penicillium paneum despite of mild effects on membrane permeability, respiration, intracellular pH, and changes the protein composition. FEMS Microbiol. Ecol. 2005;54:67–75. doi: 10.1016/j.femsec.2005.02.013. [DOI] [PubMed] [Google Scholar]
  • 12.Herrero-Garcia E, Garzia A, Cordobés S, Espeso EA, Ugalde U. 8-Carbon oxylipins inhibit germination and growth, and stimulate aerial conidiation in Aspergillus nidulans. Fungal Biol. 2011;115:393–400. doi: 10.1016/j.funbio.2011.02.005. [DOI] [PubMed] [Google Scholar]
  • 13.Singh D, Lee CH. Volatiles mediated interactions between Aspergillus oryzae strains modulate morphological transition and exometabolomes. Front. Microbiol. 2018;9:628. doi: 10.3389/fmicb.2018.00628. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 14.Singh D, Lee CH. Intraspecies volatile interactions affect growth rates and exometabolomes in Aspergillus oryzae KCCM 60345. J. Microbiol. Biotechnol. 2018;28:199–209. doi: 10.4014/jmb.1711.11005. [DOI] [PubMed] [Google Scholar]
  • 15.Calvo AM, Cary JW. Association of fungal secondary metabolism and sclerotial biology. Front. Microbiol. 2015;6:62. doi: 10.3389/fmicb.2015.00062. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 16.Grintzalis K, Vernardis SI, Klapa MI, Georgiou CD. Role of oxidative stress in sclerotial differentiation and aflatoxin B1 biosynthesis in Aspergillus flavus. Appl. Environ. Microbiol. 2014;80:5561–5571. doi: 10.1128/AEM.01282-14. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 17.Kovač T, et al. Aspergillus flavus NRRL 3251 growth, oxidative status, and aflatoxins production ability in vitro under different illumination regimes. Toxins. 2018;10:528. doi: 10.3390/toxins10120528. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 18.Risticevic S, Lord H, Gorecki T, Arthur CL, Pawliszyn J. Protocol for solid-phase microextraction method development. Nat. Protoc. 2010;5:122. doi: 10.1038/nprot.2009.179. [DOI] [PubMed] [Google Scholar]
  • 19.Yabe K, Nakajima H. Enzyme reactions and genes in aflatoxin biosynthesis. Appl. Microbiol. Biotechnol. 2004;64:745–755. doi: 10.1007/s00253-004-1566-x. [DOI] [PubMed] [Google Scholar]
  • 20.Cary JW, et al. Functional characterization of a veA-dependent polyketide synthase gene in Aspergillus flavus necessary for the synthesis of asparasone, a sclerotium-specific pigment. Fungal Genet. Biol. 2014;64:25–35. doi: 10.1016/j.fgb.2014.01.001. [DOI] [PubMed] [Google Scholar]
  • 21.Cary JW, et al. Functional characterization of a veA-dependent polyketide synthase gene in Aspergillus flavus necessary for the synthesis of asparasone, a sclerotium-specific pigment. Fungal Genet. Biol. 2014;64:25–35. doi: 10.1016/j.fgb.2014.01.001. [DOI] [PubMed] [Google Scholar]
  • 22.Fischer GJ, Keller NP. Production of cross-kingdom oxylipins by pathogenic fungi: an update on their role in development and pathogenicity. J. Microbiol. 2016;54:254–264. doi: 10.1007/s12275-016-5620-z. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 23.Fountain J, et al. Environmental influences on maize-Aspergillus flavus interactions and aflatoxin production. Front. Microbiol. 2014;5:40. doi: 10.3389/fmicb.2014.00040. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 24.Yang ZY, et al. Detection of aflatoxin-producing molds in Korean fermented foods and grains by multiplex PCR. J. Food Prot. 2004;67:2622–2626. doi: 10.4315/0362-028x-67.11.2622. [DOI] [PubMed] [Google Scholar]
  • 25.Varga J, Frisvad JC, Samson R. Two new aflatoxin producing species, and an overview of Aspergillus section Flavi. Stud. Mycol. 2011;69:57–80. doi: 10.3114/sim.2011.69.05. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 26.Jung YJ, Chung SH, Lee HK, Chun HS, Hong SB. Isolation and identification of fungi from a meju contaminated with aflatoxins. J. Microbiol. Biotechnol. 2012;22:1740–1748. doi: 10.4014/jmb.1207.07048. [DOI] [PubMed] [Google Scholar]
  • 27.Kuribayashi T, Kaise H, Uno C, Hara T, Hayakawa T, Joh T. Purification and characterization of lipoxygenase from Pleurotus ostreatus. J. Agric. Food Chem. 2002;50:1247–1253. doi: 10.1021/jf0112217. [DOI] [PubMed] [Google Scholar]
  • 28.Brodhun F, Schneider S, Göbel C, Hornung E, Feussner I. PpoC from Aspergillus nidulans is a fusion protein with only one active haem. Biochem. J. 2010;425:553–565. doi: 10.1042/BJ20091096. [DOI] [PubMed] [Google Scholar]
  • 29.Pennerman KK, Scarsella JB, Yin GH, Hua SST, Hartman TG, Bennett JW. Volatile 1-octen-3-ol increases patulin production by Penicillium expansum on a patulin-suppressing medium. Mycotoxin Res. 2019;1:12. doi: 10.1007/s12550-019-00348-w. [DOI] [PubMed] [Google Scholar]
  • 30.Yin G, et al. Influence of R and S enantiomers of 1-octen-3-ol on gene expression of Penicillium chrysogenum. J. Ind. Microbiol. Biotechnol. 2019;46:977–991. doi: 10.1007/s10295-019-02168-4. [DOI] [PubMed] [Google Scholar]
  • 31.Padhi S, Itamar D, Joan WB. Two volatile-phase alcohols inhibit growth of Pseudogymnoascus destructans, causative agent of white-nose syndrome in bats. Mycology. 2017;8:11–16. [Google Scholar]
  • 32.Mellon JE, Cotty PJ, Dowd MK. Aspergillus flavus hydrolases: their roles in pathogenesis and substrate utilization. Appl. Microbiol. Biotechnol. 2007;77:497–504. doi: 10.1007/s00253-007-1201-8. [DOI] [PubMed] [Google Scholar]
  • 33.Krijgsheld P, et al. Deletion of flbA results in increased secretome complexity and reduced secretion heterogeneity in colonies of Aspergillus niger. J. Proteome Res. 2013;12:1808–1819. doi: 10.1021/pr301154w. [DOI] [PubMed] [Google Scholar]
  • 34.Hu Y, Yang G, Zhang D, Liu Y, Li Y, Lin G. The PHD Transcription Factor Rum1 Regulates Morphogenesis and Aflatoxin Biosynthesis in Aspergillus flavus. Toxins. 2018;10:301. doi: 10.3390/toxins10070301. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 35.Schroeckh V, et al. Intimate bacterial–fungal interaction triggers biosynthesis of archetypal polyketides in Aspergillus nidulans. Proc. Natl. Acad. Sci. USA. 2009;106:14558–14563. doi: 10.1073/pnas.0901870106. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 36.Luo F, Zhong Z, Liu L, Igarashi Y, Xie D, Li N. Metabolomic differential analysis of interspecific interactions among white rot fungi Trametes versicolor, Dichomitus squalens and Pleurotus ostreatus. Sci. Rep. 2017;7:5265. doi: 10.1038/s41598-017-05669-3. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 37.Schmidt R, et al. Fungal volatile compounds induce production of the secondary metabolite Sodorifen in Serratia plymuthica PRI-2C. Sci. Rep. 2017;7:862. doi: 10.1038/s41598-017-00893-3. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 38.Venkatesh N, Keller NP. Mycotoxins in conversation with bacteria and fungi. Front. Microbiol. 2019;10:403. doi: 10.3389/fmicb.2019.00403. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 39.Da Silva E, Bracarense A, Oswald I. Mycotoxins and oxidative stress: where are we? World Mycotoxin J. 2018;11:113–134. [Google Scholar]
  • 40.Singh D, Son SY, Lee CH. Perplexing metabolomes in fungal-insect trophic interactions: A Terra incognita of mycobiocontrol mechanisms. Front. Microbiol. 2016;7:1678. doi: 10.3389/fmicb.2016.01678. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 41.Padder S, Prasad R, Shah AH. "Quorum sensing: a less known mode of communication among fungi. Microbiol. Res. 2018;210:51–58. doi: 10.1016/j.micres.2018.03.007. [DOI] [PubMed] [Google Scholar]
  • 42.Brown SH, Zarnowski R, Sharpee W, Keller N. Morphological transitions governed by density dependence and lipoxygenase activity in Aspergillus flavus. Appl. Environ. Microbiol. 2008;74:5674–5685. doi: 10.1128/AEM.00565-08. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 43.Magan, N., Hope, R., Cairns, V. & Aldred, D. Post-harvest fungal ecology: impact of fungal growth and mycotoxin accumulation in stored grain. In Epidemiology of Mycotoxin Producing Fungi, 723–730 (Springer, 2003).
  • 44.Miller JD, McMullin DR. Fungal secondary metabolites as harmful indoor air contaminants: 10 years on. Appl. Microbiol. Biotechnol. 2014;98:9953–9966. doi: 10.1007/s00253-014-6178-5. [DOI] [PubMed] [Google Scholar]
  • 45.Singh D, Lee S, Lee CH. Fathoming Aspergillus oryzae metabolomes in formulated growth matrices. Crit. Rev. Biotechnol. 2019;39:35–49. doi: 10.1080/07388551.2018.1490246. [DOI] [PubMed] [Google Scholar]
  • 46.Costa CP, Silva DG, Rudnitskaya A, Almeida A, Rocha SM. Shedding light on Aspergillus niger volatile exometabolome. Sci. Rep. 2016;6:27441. doi: 10.1038/srep27441. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 47.Heddergott C, Calvo A, Latgé J. The volatome of Aspergillus fumigatus. Eukaryot. cell. 2014;13:1014–1025. doi: 10.1128/EC.00074-14. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 48.Skogerson K, Wohlgemuth G, Barupal DK, Fiehn O. The volatile compound BinBase mass spectral database. BMC Bioinform. 2011;12:321. doi: 10.1186/1471-2105-12-321. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 49.Chancharoonpong C, Hsieh PC, Sheu SC. Enzyme production and growth of Aspergillus oryzae S. on soybean koji fermentation. APCBEE Proc. 2012;2:57–61. [Google Scholar]
  • 50.Uka V, Moore G, Arroyo-Manzanares N, Nebija D, De Saeger S, Diana Di Mavungu J. Unraveling the diversity of the cyclopiazonic acid family of mycotoxins in Aspergillus flavus by UHPLC triple-TOF HRMS. Toxins. 2017;9:35. doi: 10.3390/toxins9010035. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 51.Carvajal-Campos A, et al. Aspergillus korhogoensis, a novel aflatoxin producing species from the Côte d’Ivoire. Toxins. 2017;9:353. doi: 10.3390/toxins9110353. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 52.Malysheva SV, et al. Identification of novel metabolites from Aspergillus flavus by high resolution and multiple stage mass spectrometry. Food Addit. Contam. A. 2014;31:111–120. doi: 10.1080/19440049.2013.859743. [DOI] [PubMed] [Google Scholar]
  • 53.Fouillaud M, Venkatachalam M, Girard-Valenciennes E, Caro Y, Dufossé L. Anthraquinones and derivatives from marine-derived fungi: structural diversity and selected biological activities. Mar. Drugs. 2016;14:64. doi: 10.3390/md14040064. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 54.Tripathi B, et al. Potential antioxidant anthraquinones isolated from Rheum emodi showing nematicidal activity against Meloidogyne incognita. J. Chem. 2014;2014:1–9. [Google Scholar]
  • 55.Laakso JA, Gloer JB, Wicklow DT, Dowd PF. Sulpinines AC and secopenitrem B: new antiinsectan metabolites from the sclerotia of Aspergillus sulphureus. J. Org. Chem. 1992;57:2066–2071. [Google Scholar]
  • 56.Son SY, Lee S, Singh D, Lee NR, Lee DY, Lee CH. Comprehensive secondary metabolite profiling toward delineating the solid and submerged-state fermentation of Aspergillus oryzae KCCM 12698. Front. Microbiol. 2018;9:1076. doi: 10.3389/fmicb.2018.01076. [DOI] [PMC free article] [PubMed] [Google Scholar]
  • 57.Shao CL, et al. Aspergilones A and B, two benzylazaphilones with an unprecedented carbon skeleton from the gorgonian-derived fungus Aspergillus sp. Bioorg. Med. Chem. Lett. 2011;21:690–693. doi: 10.1016/j.bmcl.2010.12.005. [DOI] [PubMed] [Google Scholar]
  • 58.Kimura Y, Hamasaki T, Isogai A, Nakajima H. Structure of aszonapyrone A, a new metabolite produced by Aspergillus zonatus. Agric. Biol. Chem. 1982;46:1963–1965. [Google Scholar]

Associated Data

This section collects any data citations, data availability statements, or supplementary materials included in this article.

Supplementary Materials

Supplementary Information. (2.5MB, docx)

Data Availability Statement

The data in this study are available from the corresponding author upon reasonable request.

Articles from Scientific Reports are provided here courtesy of Nature Publishing Group

RESOURCES