Preclinical Evaluation of ²²⁵Ac-Labeled Single-Domain Antibody for the Treatment of HER2^pos Cancer

Abstract

Human epidermal growth factor receptor type 2 (HER2) is overexpressed in various cancers; thus, HER2-targeting single-domain antibodies (sdAb) could offer a useful platform for radioimmunotherapy. In this study, we optimized the labeling of an anti-HER2-sdAb with the α-particle-emitter ²²⁵Ac through a DOTA-derivative. The formed radioconjugate was tested for binding affinity, specificity and internalization properties, whereas cytotoxicity was evaluated by clonogenic and DNA double-strand-breaks assays. Biodistribution studies were performed in mice bearing subcutaneous HER2^pos tumors to estimate absorbed doses delivered to organs and tissues. Therapeutic efficacy and potential toxicity were assessed in HER2^pos intraperitoneal ovarian cancer model and in healthy C57Bl/6 mice. [²²⁵Ac]Ac-DOTA-2Rs15d exhibited specific cell uptake and cell-killing capacity in HER2^pos cells (EC₅₀ = 3.9 ± 1.1 kBq/mL). Uptake in HER2^pos lesions peaked at 3 hours (9.64 ± 1.69% IA/g), with very low accumulation in other organs (<1% IA/g) except for kidneys (11.69 ± 1.10% IA/g). α-camera imaging presented homogeneous uptake of radioactivity in tumors, although heterogeneous in kidneys, with a higher signal density in cortex versus medulla. In mice with HER2^pos disseminated tumors, repeated administration of [²²⁵Ac]Ac-DOTA-2Rs15d significantly prolonged survival (143 days) compared to control groups (56 and 61 days) and to the group treated with HER2-targeting mAb trastuzumab (100 days). Histopathologic evaluation revealed signs of kidney toxicity after repeated administration of [²²⁵Ac]Ac-DOTA-2Rs15d. [²²⁵Ac]Ac-DOTA-2Rs15d efficiently targeted HER2^pos cells and was effective in treatment of intraperitoneal disseminated tumors, both alone and as an add-on combination with trastuzumab, albeit with substantial signs of inflammation in kidneys. This study warrants further development of [²²⁵Ac]Ac-DOTA-2Rs15d.

Introduction

Targeted alpha therapy (TAT) exploits a combination of an α-particle emitting radionuclide and a targeting moiety, which allows specific delivery of cytotoxic radiation to cancerous cells. Because of their limited path length, α-particles are of particular interest for the treatment of residual and metastatic diseases. Several relevant radionuclides for TAT are currently under (pre-)clinical evaluation (1, 2). ²²⁵Ac (t_1/2 = 9.9 days) is an interesting radionuclide due to the emission of four α-particles in its decay chain with a total deposited α-energy of 27.6 MeV. Several clinical trials have shown high potential of ²²⁵Ac-based TAT to treat advanced cancers (3, 4). It has recently been demonstrated that TAT with [²²⁵Ac]Ac-PSMA-617 could overcome emerging radio-resistance to β⁻-particle radiation. Moreover, the shorter range of α-particles in tissue impacts hematologic toxicity in treated patients with diffuse red marrow infiltration as these particles cause less toxicity compared with β⁻-emitting radionuclides such as ⁹⁰Y and ¹⁷⁷Lu, which release cytotoxic particles with significant longer path lengths (5, 6).

Several ²²⁵Ac-labeled monoclonal antibodies (mAb) are being investigated in phase I/II clinical trials to treat hematologic cancers (7, 8). However, the success of mAb-based TAT in epithelial solid tumors is limited due to toxicities in well-perfused organs. High-binding affinity and specificity, fast clearance from blood, and the ability to homogeneously distribute in target tissues make small-sized single-domain antibodies (sdAb) promising targeting molecules for TAT (9–12). Previously, a HER2-targeting sdAb was successfully radiolabeled with therapeutic radioisotopes such as ²²⁵Ac, ²¹¹At, and ¹⁷⁷Lu (10, 11, 13). [²²⁵Ac]Ac-DOTA-2Rs15d was found to be effective in inhibiting the HER2^pos cells proliferation in a dose-dependent manner and in vivo accumulated in a HER2^pos tumor in a specific way (10), with uptake values comparable with what has been measured for its ¹⁷⁷Lu-labeled counterpart (13). However, in contrast to the ¹⁷⁷Lu-labeled variant, elevated liver uptake was observed, likely due to ²²⁵Ac nonspecifically bound to the sdAb, which might have resulted in an in vivo dissociation and accumulation in liver, as noticed earlier (10). In addition, it was shown to be effective in mice bearing intracranial HER2^pos tumor xenografts (14). In this study, the same sdAb was radiolabeled with ²²⁵Ac using optimized reaction conditions, and fully characterized in vitro, after which its therapeutic efficacy was assessed in mice with intraperitoneal HER2^pos tumor xenografts.

Materials and Methods

Preparation of [²²⁵Ac]Ac-DOTA-sdAbs

All reagents were at least analytic grade and purchased from Sigma Aldrich, unless stated otherwise. ²²⁵Ac was obtained from ²²⁹Th source by radiochemical separation (15). The HER2-targeting sdAb 2Rs15d (PDB ID: 5My6, full sequence is in the Supplementary Material) and the nontargeting control sdAb R3B23 (16) were coupled to p-SCN-Bn-DOTA chelator and radiolabeled with ²²⁵Ac as described elsewhere (10). Briefly, the desired activity (2.0–8.7 MBq) of ²²⁵Ac was mixed with 0.8 mol/L ammonium acetate (pH 5.0) and incubated with sdAb-DOTA (100–150 μg) for 90 minutes at 55°C. The mixture was cooled to room temperature, quenched with 50 mmol/L DTPA and Chelex 100 (Bio-Rad Laboratories) to complex free ²²⁵Ac, followed by purification on a PD-10 column (GE Healthcare), collected in 0.9% NaCl containing 5 mg/mL L-ascorbic acid (pH 4–5, radical scavenger) and filtered through a 0.22-μm filter (Millex, Merck Millipore). Protein-associated radioactivity was determined using instant thin-layer chromatography (ITLC) on silica gel impregnated glass fiber sheets (Agilent Technologies) using 0.05 mol/L citrate buffer at pH 4.0.

Cell lines and in vitro assays

SKOV-3 (ATCC Cat# HTB-77, RRID:CVCL_0532, HER2^pos) was purchased from the American Type Culture Collection and HER2^pos SKOV-3-Luc-IP1 (SKOV3.IP1) cells were transfected to express the enzyme firefly luciferase (Fluc+). These cells were specifically generated for intraperitoneal growth (obtained as a gift from prof. Marc Bracke from Ghent University, Ghent, Belgium; ref. 17). Both cell lines were grown in McCoy's 5A supplemented with 10% fetal bovine serum, streptomycin (100 μg/mL), and penicillin (100 IU/mL), generating working cell banks of up to no more than passage 10. Working cell banks were stored in liquid nitrogen and, upon thaw, propagated for no more than 5 to 10 additional passages. Absence of Mycoplasma was confirmed (Venor GeM Classic Kit, Minerva Biolabs) before start of in vitro experiments. Besides assessment of Mycoplasma, no cell line authentication was performed.

Binding affinity, specificity and internalization of [²²⁵Ac]Ac-DOTA-sdAbs were determined as described previously (10, 18). In vitro cytotoxicity tests, including clonogenic assay (19) and determination of DNA double-strand-breaks (DSBs) via γ-H2AX foci imaging, were performed on SKOV-3 cells and described more in detail in Supplementary Material.

Animal models

Female CRL:Nu-FoxN1^nu mice (Charles River Laboratories, RRID:IMSR_CRL:088) were inoculated subcutaneously in the neck with 10×10⁶ SKOV-3 cells and grown until they reached about 100 to 250 mm³ for biodistribution studies, and intraperitoneally with 0.25 × 10⁶ SKOV-3.IP1 cells for the therapy study. Tumor growth was measured using caliper (subcutaneously) or bioluminescence imaging (i.p.; Biospace Lab, Paris) after intraperitoneally injection of 100 μL of D-luciferin (Promega). Dose escalation studies were performed in normal female C57Bl/6 mice (Charles River Laboratories, RRID:SCR_003792). All animal protocols were approved by the ethical committee of the Vrije Universiteit Brussel.

Biodistribution and organ-absorbed doses

Specificity of targeting was evaluated in mice bearing subcutaneous SKOV-3 xenografts (n = 3) of 100 to 250 mm³. These tumor volumes were reached approximately 3 weeks after subcutaneous inoculation with 10 × 10⁶ cells. Mice were injected intravenously with 20.5 ± 2.2 kBq (2.5 ± 0.3 μg) of [²²⁵Ac]Ac-DOTA-2Rs15d either alone or in the presence of 50-molar excess of 2Rs15d to block HER2-receptors, or with 24.2 ± 1.8 kBq (2.0 ± 0.5 μg) of [²²⁵Ac]Ac-DOTA-R3B23. Administrations were done in combination with 150 mg/kg of Gelofusine to reduce kidney uptake as described previously (10). Mice were euthanized 1 hour postinjection (p.i.), after which major organs and tissues were isolated, weighed, and counted along with injected standards on the automatic gamma-counter (Cobra II 5003, Canberra Packard).

In parallel, mice (n = 3) were injected intravenously with 25.8 ± 2.0 kBq (1.1 ± 0.1 μg) [²²⁵Ac]Ac-DOTA-2Rs15d together with 150 mg/kg of Gelofusine and euthanized at several time points starting from 1 hour up to 168 hours p.i., and processed as described above. The acquired uptake values, expressed as a percentage of injected activity per gram of tissue (% IA/g), were time-integrated to obtain the residence time per gram tissue by trapezoid integration method (13). The absorbed doses were calculated using S values for ²²⁵Ac obtained from RADAR phantoms (www.doseinfo-radar.com/RADARphan.html). The S value for a 1 g sphere (4.40 × 10⁻⁹ J/kBq.s) was used to calculate all organ doses (14) and includes the energy deposition of all radioactive daughters of ²²⁵Ac. The dosimetry calculation assumes that decay of all daughter radioisotopes occur in the same location as the parent radioisotope.

α-camera imaging

The ionizing-radiation quantum imaging detector (iQID) camera was used for high resolution ex vivo imaging (20). In brief, cryo-sections (10 μm) of tumors and kidneys of SKOV-3 xenografted mice coinjected with 150 mg/kg Gelofusine (n = 3/group) were transferred on a scintillation film (EJ-440; Eljen Technology). SKOV-3 tumor-bearing mice (n = 3) received 120 ± 0.4 kBq [²²⁵Ac]Ac-DOTA-2Rs15d and were sacrificed after 1, 4, and 24 hours. Images were rebinned by summing neighboring voxels to reduce the noise. The histogram and multi-term Gaussian distributions were obtained through MATLAB R2020b (RRID:SCR_001622). Homogeneity of cryo-slices was quantitatively determined by the use of area under the curve (AUC) figure of merit analogous to the method described earlier (21).

Dose escalation and therapeutic efficacy of [²²⁵Ac]Ac-DOTA-2Rs15d

First, groups of normal female C57Bl/6 mice (n = 3) were intravenously injected with 19, 38, or 75 kBq of [²²⁵Ac]Ac-DOTA-2Rs15d, or an equal volume of 0.9% NaCl with 5 mg/mL L-ascorbic acid and 150 mg/kg Gelofusine. Animals were weighed weekly and checked daily for general health and wellbeing. Mice were euthanized when one of the following endpoints were reached: (i) weight loss >20% of original body weight, (ii) physical appearance, (iii) animal behavior.

Next, mice with intraperitoneal SKOV-3.IP1 tumor xenografts (n = 8) were injected with either (i) one dose (day 7 after tumor inoculation); or (ii) three consecutive doses (on day 7, 10, 14) of 86.84 ± 8.97 kBq [²²⁵Ac]Ac-DOTA-2Rs15d (5.46 ± 1.28 μg); (iii) trastuzumab first at 7.5 mg/kg loading (190 μg) dose followed by two maintenance doses of 3.5 mg/kg (90 μg) to mimic patient treatment schemes (loading dose: day 7; maintenance dose: day 10, 14); (iv) a trastuzumab regimen as described in (iii) followed by three consecutive doses of 86.84 ± 8.97 kBq [²²⁵Ac]Ac-DOTA-2Rs15d (day 7, 10, 14); (v) three consecutive doses of 34.33 ± 21.78 kBq [²²⁵Ac]Ac-DOTA-R3B23 (6.67 ± 2.31 μg) on day 7, 10, 14; or (vi) an equal volume of vehicle solution (0.9% NaCl + 5 mg/mL L-ascorbic acid) at identical time points as the treated groups. All samples were coinjected with 150 mg/kg Gelofusine. Tumor development was measured over time using bioluminescence imaging. Dropouts were considered when one of the following endpoints was reached: (i) severe ascites, (ii) sudden >20% weight loss, (iii) physical appearance, (iv) animal behavior, (v) BLI signal exceeding 3 × 10⁸ ph/s/cm²/sr.

From all abovementioned treatment groups in both studies, various organs and tissues were isolated, fixed in formalin, and embedded in paraffin wax. Sections of 4-μm thickness were taken and stained with hematoxylin and eosin (H&E). The sections were examined by light microscopy by AnaPath Services GmbH (Liestal, Switzerland) for signs of toxicity.

Statistical analysis

All in vitro data are presented as mean ± standard deviation (SD) of at least three independent experiments. Differences in cytotoxicity or tissue uptake were tested with a one-tailed Student t test using GraphPad Prism 5.01 (RRID:SCR_002798). A P value below 0.05 was considered statistically significant. Differences in mean survival from therapy studies were analyzed with the log-rank Mantel–Cox test.

Data availability statement

Data generated in this study are included in the article or uploaded as online Supplementary Material. The raw datasets used and/or analyzed during this study are available from the corresponding author upon reasonable request.

Results

Radiolabeling and in vitro evaluation of [²²⁵Ac]Ac-DOTA-sdAbs

Mass spectrometry revealed successful p-SCN-Bn-DOTA conjugation with an average of one or two chelators per sdAb (Supplementary Fig. S1). The radiolabeling yield was >90% (n = 21) for all bioconjugates labeled with ²²⁵Ac (2.0–8.7 MBq) after 90-minute incubation at 55°C, and the radiochemical purity was >98% (n = 21) after purification on PD-10 as determined by ITLC. The specific activity of all radiolabeled compounds was 105–678 kBq/nmol.

Binding of [²²⁵Ac]Ac-DOTA-2Rs15d to HER2-receptor was specific (P < 0.001) as it could be blocked by an excess of unlabeled 2Rs15d, whereas binding of [²²⁵Ac]Ac-DOTA-R3B23 was negligible (Supplementary Fig. S2A). The determined K_D = 3.50 ± 0.17 nmol/L for [²²⁵Ac]Ac-DOTA-2Rs15d revealed high affinity toward HER2-receptor (Supplementary Fig. S2B). The level of receptor-mediated internalization measured 36.03 ± 1.73% after 1 hour and dropped to 14.83 ± 0.54% at 24 hours (Supplementary Fig. S2C).

The number of colonies decreased with increasing amounts of radioactivity (Fig. 1A). At low radioactivity (0.1–0.8 kBq/mL) the surviving fractions (SF) were approximately 100% with no significant difference between [²²⁵Ac]Ac-DOTA-2Rs15d and the control groups (P > 0.42; Supplementary Fig. S3). The increased activity of [²²⁵Ac]Ac-DOTA-2Rs15d reduced SFs to 75.2 ± 6.1% and 3.4 ± 0.7% at 1.0 and 60.0 kBq/mL, respectively, while in the presence of an excess of unlabeled 2Rs15d the SFs measured 95.9 ± 2.7% and 8.2 ± 0.7%, which was significantly higher (P < 0.004). Cells treated with nontargeting [²²⁵Ac]Ac-DOTA-R3B23 resulted in SFs of 87.1 ± 6.8% and 13.6 ± 0.9% at 1.0 and 60.0 kBq/mL, respectively (P < 0.002). In case of the highest applied radioactivity (120 kBq/mL), the resulting number of colonies was too low to observe a statistical difference between all treated groups. The calculated EC₅₀ values for the respective treatment groups were 3.9 ± 1.1 kBq/mL for [²²⁵Ac]Ac-DOTA-2Rs15d alone, 7.4 ± 1.1 kBq/mL when coincubated with an excess of unlabeled 2Rs15d, and 11.3 ± 1.1 kBq/mL for [²²⁵Ac]Ac-DOTA-R3B23. The determined D₀ values were: 20.0 ± 2.4 kBq/mL, 24.2 ± 2.2 kBq/mL and 31.7 ± 2.4 kBq/mL for [²²⁵Ac]Ac-DOTA-2Rs15d alone, blocked with an excess of unlabeled 2Rs15d and [²²⁵Ac]Ac-DOTA-R3B23, respectively (Fig. 1B).

Figure 1.

Cytotoxic activity of (i) [²²⁵Ac]Ac-DOTA-2Rs15d alone or (ii) blocked with cold 2Rs15d; and (iii) nontargeting [²²⁵Ac]Ac-DOTA-R3B23 control probe on SKOV-3 cells determined via clonogenic (A and B) and DNA double-strand break (C and D) assays. Representative images (A) and SFs (B) of SKOV-3 cells from clonogenic assay. C, The average number of γH2AX-foci quantified per cell; NT - control cells nontreated with radioactivity. D, Representative images of detected γH2AX-foci in treated SKOV-3 cells.

The number of spontaneous DNA DSBs in nontreated (NT) SKOV-3 cells was 18.9 ± 3.1 per cell, whereas in cells exposed to [²²⁵Ac]Ac-DOTA-2Rs15d, this number varied in a dose-dependent manner (Fig. 1C and D) with values of 32.6 ± 4.3, 45.5 ± 7.7, and 78.8 ± 4.9 (P < 0.03) after treatment with 15, 125, and 625 kBq/mL, respectively. In case of the two lower radioactive concentrations, the average number of DNA DSBs was higher than values obtained for cells incubated with an excess of unlabeled 2Rs15d or nontargeting [²²⁵Ac]Ac-DOTA-R3B23, however not significantly different (P = 0.215; Fig. 1C and D).

Biodistribution and dose escalation of [²²⁵Ac]Ac-DOTA-sdAbs

As presented in Fig. 2A, the accumulation of [²²⁵Ac]Ac-DOTA-2Rs15d in SKOV-3 tumors was specific and measured 7.49 ± 0.74% IA/g at 1 hour p.i., which was significantly higher than what was measured for [²²⁵Ac]Ac-DOTA-2Rs15d coadministered with excess of unlabeled 2Rs15d (2.31 ± 0.06% IA/g; P <0.00015), or for [²²⁵Ac]Ac-DOTA-R3B23 (0.25 ± 0.09% IA/g; P < 0.00004).

Figure 2.

In vivo specificity of [²²⁵Ac]Ac-DOTA-2Rs15d alone or blocked with excess of cold 2Rs15d, and nontargeting [²²⁵Ac]Ac-DOTA-R3B23 after 1 hour p.i. in subcutaneous SKOV-3 tumor-xenografted mice (A). *, P < 0.00015; **, P < 0.00004; ***, P < 0.000003. B, Time-dependent biodistribution of [²²⁵Ac]Ac-DOTA-2Rs15d in a subcutaneous SKOV-3 tumor-xenografted mouse model. C–F, Dose-escalation study of [²²⁵Ac]Ac-DOTA-2Rs15d in healthy C57Bl/6 mice with Kaplan–Meier survival plots (C) and relative body weight (D) in various groups of treated mice. Histopathologic analysis of kidney's sections from mice receiving only vehicle solution 0.9% NaCl (E) and 19 kBq of [²²⁵Ac]Ac-DOTA-2Rs15d (F).

The time-dependent biodistribution of [²²⁵Ac]Ac-DOTA-2Rs15d in SKOV-3 tumor xenografted mice is presented in Fig. 2B and Table 1. The high tumor uptake was observed already after 1 hour p.i. with a value of 8.36 ± 0.23% IA/g, increasing to 9.64 ± 1.69% IA/g at 3 hours followed by a decrease to 2.24 ± 1.00% IA/g after 168 hours. In kidneys, 8.98 ± 3.30% IA/g was measured at 1 hour, which decreased to 1.91 ± 1.15% IA/g at 168 hours. Liver and bone uptake were very low at all-time points, indicating no substantial loss of ²²⁵Ac. Radioactivity concentration in other tissues was low always (<0.85% IA/g). Tumor-to-liver ratios increased from 12.62 ± 0.73 at 1 hour to 33.40 ± 12.13 at 6 hours and later dropped to 5.60 ± 0.66 at 168 hours (Table 1), while tumor-to-kidney ratios increased from 1.03 ± 0.42 at 1 hour to 1.55 ± 0.24 at 96 hours, respectively. Organ-absorbed doses were calculated for 1 kBq of [²²⁵Ac]Ac-DOTA-2Rs15d and are summarized in Table 1. The highest absorbed dose was delivered to tumor (115.58 mGy/kBq), while kidneys received 103.50 mGy/kBq. Doses delivered to other healthy organs and tissues were very low.

Table 1.

Ex vivo time-dependent biodistribution of [²²⁵Ac]Ac-DOTA-2Rs15d co-infused with 150 mg/kg Gelofusine in a subcutaneous HER2^pos mouse tumor model (n = 3).

										Dosimetry
										Absorbed	Absorbed
Ex vivo biodistribution										Dose	Dose × RBE factor (5)
Tissue/organ	1 h	3 h	6 h	24 h	48 h	72 h	96 h	120 h	168 h	(mGy/kBq)	(mGy/kBq)
Liver	0.66 ± 0.02	0.81 ± 0.19	0.32 ± 0.09	0.79 ± 0.08	0.63 ± 0.01	0.52 ± 0.13	0.40 ± 0.11	0.44 ± 0.04	0.41 ± 0.18	13.56	67.80
Spleen	0.25 ± 0.14	0.33 ± 0.02	0.17 ± 0.14	0.41 ± 0.07	0.23 ± 0.07	0.15 ± 0.06	0.16 ± 0.02	0.12 ± 0.01	0.15 ± 0.01	5.10	25.50
Lungs	0.15 ± 0.05	0.09 ± 0.01	0.05 ± 0.03	0.06 ± 0.02	0.07 ± 0.01	0.03 ± 0.03	0.02 ± 0.01	0.03 ± 0.01	0.04 ± 0.01	1.08	5.40
Heart	0.10 ± 0.02	0.06 ± 0.02	0.05 ± 0.01	0.10 ± 0.04	0.06 ± 0.04	0.05 ± 0.04	0.05 ± 0.05	0.06 ± 0.05	0.06 ± 0.03	1.59	7.95
Stomach	0.14 ± 0.03	0.11 ± 1.07	0.04 ± 0.00	0.05 ± 0.03	0.04 ± 0.02	0.03 ± 0.00	0.03 ± 0.01	0.02 ± 0.01	0.04 ± 0.01	0.97	4.85
Kidneys	8.98 ± 3.30	11.69 ± 1.1	10.31 ± 0.6	6.08 ± 0.27	4.13 ± 0.20	2.80 ± 0.71	1.93 ± 0.13	3.35 ± 1.03	1.91 ± 1.15	103.50	517.50
Lg. Int.	0.05 ± 0.03	0.08 ± 0.01	0.04 ± 0.00	0.05 ± 0.01	0.04 ± 0.01	0.01 ± 0.01	0.01 ± 0.01	0.02 ± 0.01	0.02 ± 0.00	0.62	3.10
Sm. Int.	0.07 ± 0.01	0.05 ± 0.00	0.04 ± 0.01	0.03 ± 0.00	0.01 ± 0.02	0.02 ± 0.01	0.01 ± 0.02	0.01 ± 0.00	0.01 ± 0.01	0.44	2.20
Pancreas	0.04 ± 0.02	0.03 ± 0.00	0.08 ± 0.11	0.03 ± 0.02	0.02 ± 0.00	0.02 ± 0.00	0.01 ± 0.01	0.01 ± 0.00	0.02 ± 0.00	0.57	2.85
Muscle	0.08 ± 0.03	0.03 ± 0.01	0.04 ± 0.01	0.02 ± 0.02	0.01 ± 0.01	0.02 ± 0.01	0.02 ± 0.00	0.03 ± 0.01	0.04 ± 0.02	0.64	3.20
Blood	0.23 ± 0.20	0.01 ± 0.01	0.01 ± 0.00	0.14 ± 0.21	0.13 ± 0.23	0.05 ± 0.08	0.23 ± 0.36	0.07 ± 0.04	0.18 ± 0.00	2.55	12.75
Bone	0.29 ± 0.06	0.10 ± 0.01	0.09 ± 0.04	0.36 ± 0.06	0.32 ± 0.10	0.06 ± 0.02	0.06 ± 0.01	0.05 ± 0.06	0.08 ± 0.03	3.62	18.10
Tumor	8.36 ± 0.23	9.64 ± 1.69	9.87 ± 1.38	6.58 ± 1.78	6.20 ± 1.00	4.24 ± 0.68	3.73 ± 0.58	1.70 ± 0.64	2.24 ± 1.00	115.58	577.90
T-to-Liver	12.62 ± 0.73	12.08 ± 1.71	33.40 ± 12.13	8.29 ± 1.59	9.79 ± 1.61	8.31 ± 1.10	9.60 ± 1.23	3.78 ± 1.06	5.60 ± 0.66	—	—
T-to-Kidneys	1.03 ± 0.42	0.82 ± 0.13	0.95 ± 0.08	1.08 ± 0.30	1.50 ± 0.22	1.55 ± 0.24	1.92 ± 0.18	0.60 ± 0.46	1.54 ± 1.32	—	—

Note: Results are presented as mean % IA/g ± SD. Dosimetry data are expressed as mGy/kBq.

In a dose escalation study, groups of normal female C57Bl/6 mice received a single administration of increasing radioactive amounts of [²²⁵Ac]Ac-DOTA-2Rs15d ranging 19–75 kBq or nonradioactive vehicle solution (control). All animals in the control group were included until the end of the study (200 days) and sacrificed at the end. In that case, the mean survival was considered undefined. Animal groups that received 75 and 38 kBq counted for a mean survival of 166 and 145 days, respectively (P = 0.277; Fig. 2C). Weight progression during dose escalation study of [²²⁵Ac]Ac-DOTA-2Rs15d in healthy C57Bl/6 mice is presented in Fig. 2D. Histopathologic analysis resulted in mild to serious tubulopathy in mice receiving [²²⁵Ac]Ac-DOTA-2Rs15d (Fig. 2E and F; Table 2).

Table 2.

Histopathologic analysis of kidneys sections from mice enrolled in the dose escalation study.

	Groups (kBq)
	Control
	(0 kBq)	19 kBq	38 kBq	75 kBq
Total animals	3	3	3	3
Tubular cast, hyaline	1/1.0	2/2.0	3/1.6	3/1.3
Tubular basophilia	1/1.0	0	0	0
Tubular dilation	0	3/2.6	3/3.3	3/2.6
Cytoplasmic vacuolation	0	3/2.6	3/3.0	3/2.6
Tubular necrosis	0	3/3.0	3/3.6	3/3.3
Tubular regeneration	0	3/4.0	3/5.0	3/4.3
Fibrosis interstitial	0	3/3.0	3/3.0	3/3.6
Inflammation	2/1.0	3/2.0	3/2.0	3/2.6
Mononuclear foci	1/1.0	2/2.0	3/1.6	3/1.0
Karyomegaly	0	3/1.3	3/1.3	3/2.0
Glomerular atrophy	0	3/1.3	2/1.5	3/2.0
Mineralization	0	1/2.0	0	1/1.0
Pelvis dilation	1/1.0	0	0	0

Note: Kidney sections were stained with H&E. Incidence and mean severity of findings in kidney. Grade 1, minimal; grade 2, slight; grade 3, moderate; grade 4, marked; grade 5, severe; description of the severity scores is detailed in the Supplementary Material.

Digital autoradiography of tumors and kidneys was used to evaluate distribution of radioactivity after injection of [²²⁵Ac]Ac-DOTA-2Rs15d with coinfusion of Gelofusine at 1, 4, and 24 hours (Fig. 3). A clear intratumoral distribution was observed already 1 hour p.i. and was maintained until 24 hours (Fig. 3A). In kidneys, α-imaging at 1, 4, and 24 hours revealed marked differences in intrarenal activity distribution (Fig. 3B). At 1 hour, high-intensity areas of activity were observed in the cortical region, decreasing over time indicating efficient clearance of [²²⁵Ac]Ac-DOTA-2Rs15d. Fig. 3C presents a quantitative analysis of the activity distribution from the kidney 4 hours p.i. depicted in Fig. 3B. The extracted histogram shows a nonuniform uptake. Multi-term Gaussian distributions were fitted to the histogram data of cortex ROI. From Fig. 3D, a wash-out over time can be observed. Homogeneity was assessed by plots where the total signal fraction is displayed as a function of the total area fraction. A completely uniform ROI corresponds to a linear function and an AUC of 0.5. Both cortex ROIs (Fig. 3E) as well as ROIs encompassing the whole tumor slice (Fig. 3F) show uniform activity distributions - cortex: 0.6186 (1 hour), 0.6042 (4 hours), 0.6274 (24 hours); and tumors: 0.6754 (1 hour), 0.6477 (4 hours), 0.6092 (24 hours).

Figure 3.

α-camera imaging of [²²⁵Ac]Ac-DOTA-2Rs15d activity distribution in cryo-sectioned HER2^pos tumors (A) and kidneys (B) of subcutaneous SKOV-3 xenografts. All images were taken at 1, 4, and 24 hours p.i. C, Histogram of the activity distribution of an α-camera image of kidneys 4 hours p.i. derived from ROIs encompassing the whole kidney area, including both cortex and medulla. D, Multi-term gaussian plots fitted to the histogram data of cortex ROI. Homogeneity of cortex (E) and tumor (F) was assessed by plots where the total signal fraction is displayed as a function of the total area fraction. A completely uniform ROI corresponds to a linear function (depicted as a dashed line) and an area under the curve (AUC) of 0.5.

Therapeutic efficacy of [²²⁵Ac]Ac-DOTA-2Rs15d

The therapeutic efficacy study scheme is presented in Fig. 4A. Both a single and three consecutive administrations of [²²⁵Ac]Ac-DOTA-2Rs15d resulted in a significantly longer mean survival of 101 and 143 days, respectively, versus 56 days for mice receiving vehicle solution (P < 0.0001; Fig. 4B). No significant difference (P = 0.2151) in survival was observed between negative control groups receiving vehicle (56 days) or [²²⁵Ac]Ac-DOTA-R3B23 (61 days). No significant difference in mean survival was observed between the trastuzumab regimen (100 days) and a single administration of [²²⁵Ac]Ac-DOTA-2Rs15d (101 days; P = 1.000), while three consecutive doses of [²²⁵Ac]Ac-DOTA-2Rs15d (143 days) increased the mean survival compared with the group receiving trastuzumab regimen or a single dose of [²²⁵Ac]Ac-DOTA-2Rs15d (P < 0.0389). Trastuzumab regimen alone led to a mean survival of 100 days, while trastuzumab regimen together with three consecutive injections of [²²⁵Ac]Ac-DOTA-2Rs15d as an add-on therapy increased mean survival to 161 days; however, not significantly different from each other (P = 0.0558). These results are confirmed by a more stable weight, indicating less tumor progression for all mice treated with three repeated doses of [²²⁵Ac]Ac-DOTA-2Rs15d alone or together with trastuzumab (Fig. 4C). The calculated absorbed dose for single 85 kBq and the cumulative therapeutic activity 255 kBq (3 × 85 kBq) of [²²⁵Ac]Ac-DOTA-2Rs15d is about 9.8 and 29.5 Gy in tumor, whereas in kidneys is 8.8 and 26.4 Gy, respectively (Fig. 4D).

Figure 4.

Therapy with [²²⁵Ac]Ac-DOTA-2Rs15d improves survival of mice bearing disseminated intraperitoneal SKOV3.IP1 tumors. Treatment schedules (A) and Kaplan–Meier survival plots (B) together with relative body weight (C) in various groups of treated mice. D, Calculated absorbed doses (Gy), without considering of RBE factor 5 for α-particles, in normal organs and tumor for one single therapeutic injection 85 kBq and total therapeutic activity 255 kBq of [²²⁵Ac]Ac-DOTA-2Rs15d. H&E sections of kidneys from mice receiving 0.9% NaCl (E), one single dose (F) and three injections (G) of [²²⁵Ac]Ac-DOTA-2Rs15d.

The antitumor effect of [²²⁵Ac]Ac-DOTA-2Rs15d was confirmed through bioluminescence imaging (Supplementary Fig. S4). Disease progression was retarded for animal groups treated with trastuzumab or [²²⁵Ac]Ac-DOTA-2Rs15d compared with control groups. Mice that received repeated injections of [²²⁵Ac]Ac-DOTA-2Rs15d alone or in combination with trastuzumab revealed a complete absence of BLI signal over time. However, histopathologic evaluation of kidneys revealed a number of substantial inflammatory lesions consisting of tubular dilation in mice receiving a single (85 kBq) and triple dose (3 × 85 kBq = 255 kBq) of [²²⁵Ac]Ac-DOTA-2Rs15d, while this was not observed in animals that received vehicle solution (Fig. 4E–G).

Discussion

In this study, we report a complete in vitro and in vivo evaluation of the HER2-targeting sdAb 2Rs15d radiolabeled with the α-particle emitter ²²⁵Ac. 2Rs15d has been evaluated previously as a vector for both imaging (22–25) and targeted radionuclide therapy (TRNT; refs. 13, 14, 26), and is characterized by high binding specificity and affinity to HER2-receptor, and high tumor-to-background ratios in vivo. Fast clearance from blood allows repeated administration, though, with a risk of inducing long-term toxicity to kidneys. Indeed, depending on the radionuclide used, fast clearance of radiolabeled sdAb can result in significant accumulation and retention of radioactivity in kidneys. However, radioactive dose fractionation has already indicated in the clinic that it can reduce toxicity to critical organs and tissues in patients with multi-resistant neuroendocrine tumors (3) as this strategy allows time for healthy tissue regeneration. Results of preclinical therapy studies with ²²⁵Ac-labeled trastuzumab (27) also suggest that fractionation is more effective particularly in treatment of larger metastatic-clusters, as it avoids early mortality that is seen when administering single high radioactive dose.

A few preclinical studies have described HER2-sdAb–based TRNT using α-particle emitting radionuclides (11, 14, 28). We recently reported therapeutic efficacy [²²⁵Ac]Ac-DOTA-2Rs15d in mice with intracranial HER2^pos tumor xenografts (14). The combination of trastuzumab and [²²⁵Ac]Ac-DOTA-2Rs15d resulted in a significant increase in survival compared with control groups. In addition, [²¹³Bi]Bi-DTPA-2Rs15d revealed to be promising with confirmed therapeutic efficacy in mice bearing intraperitoneal HER2^pos tumor xenografts (28). Nonetheless, in vivo TAT appeared to be challenging due to the very short half-life of ²¹³Bi and resulted in a therapeutic index below 0.5. MAbs (e.g., lintuzumab) radiolabeled with ²¹³Bi and ²²⁵Ac were evaluated for various types of cancer (29, 30); however, accumulation of cytotoxic radiation in critical organs such as liver and bone marrow remains a major dose-limiting factor for mAbs. The recent clinical successes using ²²⁵Ac-labeled peptides such as PSMA-617, Substance P and Octreotide have shown their potential in TAT (5, 31, 32). In this study, we further investigated the use of [²²⁵Ac]Ac-DOTA-2Rs15d to treat intraperitoneal metastatic disease in mice.

[²²⁵Ac]Ac-DOTA-2Rs15d was obtained with high radiochemical yield and specific activity. Addition of DTPA and Chelex 100 prior to purification improved the radiochemical purity of a final product compared to what was reported before (10). [²²⁵Ac]Ac-DOTA-2Rs15d bound HER2-receptor specifically both in vitro and in vivo, and targeting capacity was not affected by conjugation of two chelators per one sdAb. The level of receptor-mediated internalization of [²²⁵Ac]Ac-DOTA-2Rs15d was higher compared to 2Rs15d radiolabeled with ²¹¹At via [²¹¹At]At-SGMAB (ca. 15% at 1–24 hours), [²¹¹At]At-SAB (ca. 25% at 1 hour and 15% at 24 hours) and [²¹¹At]At-MSB (ca. 25% at 1 hour and 20% at 24 hours) or with ¹³¹I through [¹³¹I]I-SGMIB (9.13 ± 2.37% at 1 hour and 14.39 ± 1.95% at 24 hours) prosthetic groups, respectively (11, 26). This is an important result taking into account a serial decay of ²²⁵Ac into radioactive daughters, because better internalization prevents the escape of those radionuclides from cancerous cells, which may result in an increased therapeutic efficacy and lower toxicity (33, 34). Higher internalization levels were observed previously for mAbs labeled with radiometals compared to radiohalogens. A potential explanation could be the increased intracellular retention of catabolic products containing radiometals, perhaps within lysosomes (35). The level of internalization obtained in this study for [²²⁵Ac]Ac-DOTA-2Rs15d seems higher than what was observed for the same sdAb labeled with radiohalogens. However, we have to keep in mind that different radiolabeling methods were used, including one- or two-step procedures as for ²¹¹At (11). In addition, the results for [¹³¹I]I-SGMIB-2Rs15d were obtained using a different cell line, BT474/M1 (26).

[²²⁵Ac]Ac-DOTA-2Rs15d was toxic to HER2^pos SKOV-3 cells, with an EC₅₀ value of 3.9 ± 1.1 kBq/mL, which was lower compared with the value obtained via the MTS assay (10.2 ± 1.2 kBq/mL; ref. 10). The clonogenic assay, performed in the current study, is considered to be more reliable as it reveals the actual number of cells that survived treatment and can further proliferate to form colonies, whereas the MTS measures the cell metabolism and does not differentiate between cells in early- or late-stage apoptosis. In vitro cytotoxic effect of [²²⁵Ac]Ac-DOTA-2Rs15d was further supported by its ability to induce irreparable DSBs in DNA. However, further assay optimization (e.g., incubation time) is still required since major differences between [²²⁵Ac]Ac-DOTA-2Rs15d and the controls were not observed. In vivo, [²²⁵Ac]Ac-DOTA-2Rs15d accumulated rapidly in tumor, with high uptake measured as early as 1 hour p.i. After 168 hours (7 days), a significant amount of radioactivity was still retained in tumor. Accumulation in normal organs and tissues was low at all time-points, except in kidneys. The observed tumor uptake corresponds well to what was previously obtained with 2Rs15d radiolabeled with ²¹¹At, ¹⁷⁷Lu, ¹⁸F, or ²¹³Bi when administered to the same mouse model (11, 13, 23, 28). We previously observed elevated liver uptake upon intravenous administration of [²²⁵Ac]Ac-DOTA-2Rs15d, probably due to nonspecific binding of ²²⁵Ac to the protein and not through stable DOTA chelator complexation. It is known that noncomplexed ²²⁵Ac highly accumulates in liver (10). Addition of an excess of DTPA to the reaction mixture right after ²²⁵Ac-complexation was described to result in reduced retention in liver (14). Therefore, in the current article, an excess of DTPA together with cationic Chelex resin was added to the reaction mixture prior to purification of [²²⁵Ac]Ac-DOTA-2Rs15d, and successfully avoided retention of radioactivity in liver.

The clearance pattern in kidneys was in line with what has been observed previously for [¹⁷⁷Lu]Lu-DOTA-2Rs15d (13) and about twice lower to that measured for [²¹³Bi]Bi-DTPA-2Rs15d (28). All radiolabeled sdAbs were coinjected with 150 mg/kg Gelofusine, which is described to reduce the kidney retention with 40% to 50% (10, 13, 14). The different physiochemical properties of radiolabeled sdAbs either with p-SCN-Bn-CHX-A”-DTPA or p-SCN-Bn-DOTA as chelating moieties might influence the stability of formed complexes and the extent of renal accumulation. Dosimetry estimations for [²²⁵Ac]Ac-DOTA-2Rs15d resulted in a therapeutic index of 1.0 compared with a therapeutic index of 0.16 for [²¹³Bi]Bi-DTPA-2Rs15d (28). An explanation for this observation might be the higher uptake in kidneys of [²¹³Bi]Bi-DTPA-2Rs15d together with the high dose rate of the latter radioisotope, which might increase the risk of inducing acute toxicity within cortical compartment of kidneys.

Therapeutic efficacy study in athymic nude mice was designed in such a way to understand the therapeutic potential, even though we assumed that the chosen doses could cause late stage toxicity, especially in kidneys. As a result, a single radioactive dose of 85 kBq [²²⁵Ac]Ac-DOTA-2Rs15d was selected based on the insights from dose escalation study. For this activity, an absorbed dose in kidneys is 8.8 Gy, whereas in case of a cumulative therapeutic activity of 255 kBq (3 × 85 kBq) [²²⁵Ac]Ac-DOTA-2Rs15d is about 26.4 Gy, which remains close to the renal toxicity threshold of 23 Gy. However, any reference to this limit should be done with care, as it was determined via external beam irradiation and assumes homogenous radiation distribution in kidneys, which is not representative in case of short-range radiation of high LET α-particles emitted from radionuclides accumulated in tissue (36). Moreover, α-camera imaging confirmed that radioactivity distribution in kidneys was heterogeneous and appeared to be concentrated in the cortical compartment of kidneys. Therefore, a mean absorbed dose to a whole organ seems not sufficient to accurately assess dose limits on an organ and sub-organ level. In addition, when considering α-particle radiation one should take into account the relative biological effectiveness (RBE) to enable comparability between doses from different radiation types. An RBE value of 5 is often used for studies with ²²⁵Ac (3, 4), which always results in a higher RBE-weighted absorbed doses to organs and tissues. As a result, the calculated RBE-weighed absorbed doses to kidneys for a single administration (85 kBq) and three consecutive administrations are 44 and 132 Gy, respectively. However, the latter dose is an extrapolation done for a single injection of 255 kBq of [²²⁵Ac]Ac-DOTA-2Rs15d, while it was administered in a fractionated regimen for therapy.

The high absorbed dose to tumor in case of [²²⁵Ac]Ac-DOTA-2Rs15d and the resulting positive impact on survival indicates increased potency of α-particle radiation over more conventional β⁻-particle radiation. Indeed, administration of 46.25 MBq of ¹³¹I-labeled 2Rs15d resulted in an absorbed dose to tumor of about 15 and 10 Gy to kidneys and led to a mean survival of about 59 days in the same tumor-xenografted mouse model (26). Repeated [²²⁵Ac]Ac-DOTA-2Rs15d injections combined with trastuzumab further increased the mean survival in comparison with trastuzumab regimen alone, which indicates the potential of ²²⁵Ac-labeled 2Rs15d as an add-on therapy to trastuzumab. Importantly, 2Rs15d binds domain I of the HER2-receptor, whereas trastuzumab binds domain IV, so no binding competition exists between both targeting moieties (24, 26). Therefore, [²²⁵Ac]Ac-DOTA-2Rs15d might be also considered as a therapeutic strategy in particular occasions where patients show resistance to treatment with trastuzumab or acquired resistance during therapy with final relapse and disease progression. Moreover, [²²⁵Ac]Ac-DOTA-2Rs15d might be applied in cases where full intact monoclonal antibodies, like trastuzumab are not effective, for example in HER2^pos brain lesions (14). Despite very convincing therapeutic efficacy results presented in this study, there is also an indication of renal toxicity at high radioactive doses. Small radiolabeled peptides and proteins, such as [²²⁵Ac]Ac-DOTA-2Rs15d, are characterized by fast blood clearance and in a few cases these are subsequently retained in kidneys. More so, ²¹³Bi which originates from the decay of ²²⁵Ac accumulates in kidneys as well (33). Both pose concerns towards off-target toxicity. In case of ²¹³Bi, the chelation of free radiometal, competitive metal blockade, or the acceleration of renal clearance can reduce the accumulation of ²²⁵Ac daughters in kidneys (34). So far, clinical cases describing peptide-based TAT using ²²⁵Ac revealed no acute or sub-acute renal toxicity (32). Although, not obtained in randomized clinical trials, these early results indicate that the toxicity profile in a clinical setting is not yet fully understood and that the herein presented preclinical results should be interpreted with care. Nevertheless, high kidney uptake of [²²⁵Ac]Ac-DOTA-2Rs15d underlines the need for thorough dose-reduction studies to identify the ideal dose and fractionation scheme to achieve treatment efficacy while keeping toxicity to kidneys minimal. In addition, it is worthwhile investigating how to further reduce the retention of radioactivity in kidneys. One possible strategy is the introduction of amino acid linkers between the sdAb and chelator complex (37–40) that are designed to be cleaved at the proximal tubular brush border membrane. This might allow radiometal complex to be separated from targeting moiety prior to interaction with lumen of the renal tubules, and therefore efficiently excreted into urine. Alternatively, positively charged amino acids (L-lysine or L-arginine) either separately or as a cocktail will be used in future studies to effectively reduce kidney retention as previously shown in both preclinical (41) and clinical studies in patients injected with [¹⁷⁷Lu]Lu-DOTA-TATE, where renal toxicity was significantly reduced with positively charged amino acids (42).

The current study demonstrates effective treatment of intraperitoneal disseminated tumors using [²²⁵Ac]Ac-DOTA-2Rs15d, both alone as a single treatment as well as in combination with the HER2-targeting mAb trastuzumab. [²²⁵Ac]Ac-DOTA-2Rs15d holds promise for further investigation; however, a better understanding of dose-response and dose-toxicity relationships are needed. With the recent successful introduction of ²²⁵Ac-labeled peptides in the clinic, sdAb-based TAT might also find its way towards clinical translation.

This article is featured in Highlights of This Issue, p. 1745

Authors' Disclosures

Y. Dekempeneer reports personal fees from PRECIRIX SA outside the submitted work as well as a patent for use of sdabs for diagnosis and therapy pending and a patent for use of sdabs for diagnosis and therapy issued. B.W. Miller reports other support from QScint Imaging Solutions, LLC outside the submitted work as well as a patent for iQID patent issued and licensed to QScint Imaging Solutions. T. Lahoutte reports other support from Vrije Universiteit Brussel during the conduct of the study; personal fees from Precirix outside the submitted work as well as a patent for patent application on single domains for radionuclide therapy pending, issued, and licensed to Precirix. M. D'Huyvetter reports grants from Fonds Wetenschappelijk Onderzoek - Vlaanderen (FWO) during the conduct of the study, personal fees from Precirix SA outside the submitted work, as well as a patent for use of sdabs for diagnosis and therapy pending and a patent for use of sdabs for diagnosis and therapy issued issued. M. Pruszynski reports grants from National Science Centre, Poland and other support from PAS-FWO (Polish Academy of Sciences-Fonds Wetenschappelijk Onderzoek) during the conduct of the study. No disclosures were reported by the other authors.

Authors' Contributions

M. Rodak: Data curation, formal analysis, investigation, visualization, methodology, writing–original draft. Y. Dekempeneer: Data curation, formal analysis, investigation, visualization, methodology, writing–original draft. M. Wojewódzka: Formal analysis, methodology. V. Caveliers: Resources. P. Covens: Data curation, methodology. B.W. Miller: Resources, methodology. M.B. Sevenois: Formal analysis, methodology. F. Bruchertseifer: Resources. A. Morgenstern: Resources. T. Lahoutte: Resources. M. D'Huyvetter: Conceptualization, supervision, funding acquisition, investigation, methodology, project administration, writing–review and editing. Pruszyński: Conceptualization, resources, supervision, funding acquisition, investigation, methodology, project administration, writing–review and editing.